2002 Damon Intruder problems, complaints & recalls
Most-reported problem areas: Service Brakes, Hydraulic (2) · Visibility:windshield Wiper/Washer (1) · Structure (1)
Safety recalls (0)
No recalls on record for this model year (campaigns announced since 2010).
Service bulletins (4)
Technical service bulletins are repair instructions manufacturers send dealers for known issues. Unlike recalls, the fix is not automatically free — but naming the bulletin at the service desk can save diagnosis time and support goodwill repairs.
Structure 2002-02-01 · 02103 · Service Bulletin/Repair Instructions
a condition may exist during high temperature conditions, the rubber traction on the entry steps may loosen. *tt
Equipment 2001-10-01 · 01099 · Service Bulletin/Repair Instructions
information regarding flush floor system, may not be properly adjusted.*jb
Unknown Or Other 2001-10-01 · 01098 · Service Bulletin/Repair Instructions
subject regarding hoses being kinked at the water heater.*jb
Exterior Lighting:headlights 2001-10-01 · 01095 · Service Bulletin/Repair Instructions
information regarding headlight securement bracket may not have been secured to the fiberglass cap backer.*jb
What owners report
2017-07-26 · Fuel/Propulsion System · 23,500 mi“i purchased this rv in dec 2016 i have been on a couple small trips then went on a 1000 mile trip and found that a sway bar bolt was missing and the propane tank was rubbing on the rear leaf springs. the space between the propane tank and leaf springs is to close. i have taken a photo of the issue. i have looked for a recall but i think because o…”
2011-05-05 · Service Brakes, Hydraulic · 45,223 mi“i had a safety recall # 50401c done on 05/09/2006 to replace all 4 calipers because they might hang up and cause brake overheating and maybe a accident. at that time there was no damage and no worn of cracked parts. i was asked to return again for recall # 51101c to again replace all 4 calipers to the latest style for the same reason. this time 3 …”
2010-03-30 · Service Brakes, Hydraulic · 20,000 mi“tl*the contact owns a 2002 damon intruder rv. while driving approximately 25 mph, there was an unusual smell emitting form the braking system. the vehicle began dragging and was hesitant to accelerate. the vehicle was moved off of the road. once the vehicle cooled off for several minutes, it began operating normally. the contact was advised that th…”
2003-11-18 · Structure“left top corner windshield seal failed, and was leaking a lot of water. (2002 damon intruder 369)*ak the windshield came out at the top left hand corner and caused water to enter the rv. the dealer indicated that they didn't think it would stay in place because of structural conditions that caused the seal not to hold. *nlm…”
2003-01-02 · Visibility:windshield Wiper/Washer“consumer had difficulty checking transmission fluid. the dealer had attempted to repair the vehicle 3 times unsuccessfully. *ts *ak there was a rattle noise, the bathroom was out of line, the door /exit door didn't stay closed, the tank leaked, the windshield wiper was inoperative, and the antenna was inoperative. scc…”
Excerpts of consumer complaints filed with NHTSA, lightly truncated. They are owner statements, not verified findings.