2002 Mercedes Benz G55 problems, complaints & recalls
Most-reported problem areas: Fuel/Propulsion System (2)
Safety recalls (2)
Structure 2012-08-06 · campaign 12V380000 · 189 vehicles
Defect: Mercedes-Benz is recalling certain model year 2011 G550 and G55 (AMG) vehicles manufactured from September 20, 2010, through April 27, 2011. During the front passenger air bag deployment, parts of the molding strip could potentially become loose and become a projectile in the passenger compartment.
Risk: In the event of the passenger airbag deployment, if the molding strip comes loose, there is an increased risk of personal injury.
Fix: Mercedes-Benz will notify owners, and dealers will reinforce the connection between the molding strip and air bag cover flap, free of charge. The safety recall began on October 26, 2012. Owners may contact Mercedes-Benz at 1-800-367-6372.
Exterior Lighting:turn Signal 2010-08-05 · campaign 10V366000 · 3,552 vehicles
Defect: MERCEDES-BENZ IS RECALLING CERTAIN MODEL YEAR 2002-2010 G-CLASS VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE VEHICLES ARE EQUIPPED WITH A GRILL COVER FOR FRONT TURN SIGNAL PROTECTION THAT, WHILE PERMISSIBLE, MAY IMPACT OVER TIME THE SIGNAL'S ABILITY TO MEET THE MINIMUM REQUIREMENTS OF FMVSS 108.
Risk: THE SIGNAL LIGHT'S VISIBILITY TO OTHER MOTORISTS MAY BE REDUCED OVER TIME, INCREASING THE RISK OF A CRASH.
Fix: DEALERS WILL INSTALL IMPROVED TURN LIGHT UNITS OPTIMIZED FOR USAGE WITH GRILLS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN AT THE END OF DECEMBER 2010 OR EARLY JANUARY 2011. OWNERS MAY CONTACT MERCEDES-BENZ AT 1-800-367-6372.
Service bulletins (38)
Technical service bulletins are repair instructions manufacturers send dealers for known issues. Unlike recalls, the fix is not automatically free — but naming the bulletin at the service desk can save diagnosis time and support goodwill repairs.
Service Brakes 2026-09-22 · LI42.10-P-078779 · Service Bulletin/Repair Instructions
complaint repeat workshop visit for vehicle vibration while braking from 60mph. note: although the symptom is similar to a tire or wheel vibration, it is usually readily noticeable that it is distinctly different if it happens at all times or only while braking. cause although the cause of the vibra
Structure:body 2026-09-14 · LI82.62-P-078631 · Service Bulletin/Repair Instructions
complaint clanking noise from the area of the speakers in the doors. cause under analysis. remedy to narrow down the cause, first of all remove the door trim. • if the noise continues to occur even with the door trim removed, then continue the diagnosis working towards the speaker and if necessary,
Structure:body 2026-08-06 · LI82.62-P-078631 · Service Bulletin/Repair Instructions
complaint clanking noise from the area of the speakers in the doors. cause under analysis. remedy to narrow down the cause, first of all remove the door trim. • if the noise continues to occur even with the door trim removed, then continue the diagnosis working towards the speaker and if necessary,
Power Train 2026-07-14 · LI35.30-P-058566 · Service Bulletin/Repair Instructions
single throttle lift-off clunking noise from the side shaft when moving off (audible at the outboard end). the noise is heard once in each instance when changing direction of travel. note: sound file in attachment cause if the complaint is eliminated by experimentally loosening the outboard collar n
Structure:body 2026-03-27 · LI88.85-P-059178 · Service Bulletin/Repair Instructions
complaint wind noises/whistling noises from front area of roof or from area of instrument panel/windshield at high speeds cause the airstream can excite the rubber strip of the windshield to whistle. note: to troubleshoot, tape down the strip. remedy seal the lower lip of the rubber strip at the top
Electrical System 2025-11-06 · LI68.20-P-080012 · Service Bulletin/Repair Instructions
complaint usb port not functioning properly. cause most reported usb port issues are due to improper use or contamination. note: any repair costs must be discussed with the customer beforehand. common external factors identified include: • fluid intrusion • broken bushings or physical damage see att
Showing the 6 most recent of 38 bulletins. Search all of them free at nhtsa.gov.
What owners report
2012-12-26 · Fuel/Propulsion System · 5,000 mi“my husband and i own two of the exact, same car! they are both leaking gas infrequently. it looks to be coming from a clamp. we have video of the leak. here is the link on youtube. http://www.youtube.com/watch?v=gpat_2vwbg0&feature=share&list=uuo-albym_ieourbxawfk4lw i will file an additional complaint for the other vin. aloha. *tr…”
2012-12-26 · Fuel/Propulsion System · 5,000 mi“my husband and i own two g55's purchased on the same day. they both started leaking fuel infrequently within two weeks of each other. you can actually see the fuel dropping to the ground and smell the gas. i filed a complaint for the other vin as well. that complaint number is 10490150. the link to the youtube video showing the leak is in the …”
Excerpts of consumer complaints filed with NHTSA, lightly truncated. They are owner statements, not verified findings.