2004 Yamaha Fz6 problems, complaints & recalls
Most-reported problem areas: Fuel System, Gasoline:fuel Injection System (9) · Vehicle Speed Control (6) · Fuel System, Gasoline:delivery (5)
🛣️ Complaints by mileage
30 NHTSA complaints that reported an odometer reading.
Safety recalls (1)
Equipment 2014-04-01 · campaign 14E012000 · 2,827 vehicles
Defect: Ohlins Racing AB (Ohlins) is recalling certain steering dampers kits manufactured with an incorrectly machined bracket. These dampers were sold for use as aftermarket equipment on Yamaha R1, R6, and FZ6, Suzuki TL1000 R and GSX1300R, Honda CB600RR, and Ducati Monster 1000, 748, 848, 916, 996, and 998 motorcycles. Also included are universal steering damper kits with part numbers SD 000 through SD 005. The affected brackets may crack.
Risk: If there is a crack in the steering bracket, at low speeds it may cause the steering to lock, leading to personal injury or a crash.
Fix: Ohlins will notify the distributors and provide their customers with a new bracket. The recall began in November 2013. Owners may contact Ohlins USA at 1-828-692-4525. Note: This recall is an expansion of recall 13E-034.
Service bulletins (4)
Technical service bulletins are repair instructions manufacturers send dealers for known issues. Unlike recalls, the fix is not automatically free — but naming the bulletin at the service desk can save diagnosis time and support goodwill repairs.
Vehicle Speed Control 2006-07-26 · 2006011 · Service Bulletin/Repair Instructions
unstable engine idling. *tt
Power Train 2006-02-24 · 200603 · Service Bulletin/Repair Instructions
drive sprocket retaining nut and lock washer replacement. *tt
Equipment:other:owners/Service/Other Manual 2005-11-30 · 2005020 · Service Bulletin/Repair Instructions
service manual corrections - crankshaft journal bearing colors. *nm
Fuel System, Gasoline:delivery:hoses, Lines/Piping, And Fittings 2005-03-31 · 2005007 · Service Bulletin/Repair Instructions
service manual additions - fuel hose connector information. *tt
What owners report
2023-02-10 · Vehicle Speed Control“front drive shaft, chain sprocket ‘nut/lock washer’ has came loose and fell off on the highway. could have locked the chain around the wheel and cause a major crash, also could have severely damaged the engine casing. it damaged the rear swing arm and a piece piece near the stater. i replaced the nut & locking washer tab, exact replacement only to …”
2006-10-01 · Electrical System:ignition · 3,000 mi · 💥 crash“yamaha 2004 fz6 bike runs good for a while, and all the sudden the engine loses 90 % of its power, i have to turn the key off, then back on to regain power while in traffic, one time this happen i gave it to much gas to get out of traffic ,and i flipped the bike over in the middle of the street. it was my lucky day nobody ran over me. looking at t…”
2006-07-05 · Engine And Engine Cooling:engine · 300 mi“motorcycle shuts off after reducing throttle during deceleration and during shifting. many riders of the same model motorcycle have reported the same problem. this is dangerous because the bike is w/o power and sometimes during downshifting the rear tire loses traction and causes the bike to slide sideways. *nm…”
2006-06-13 · Vehicle Speed Control · 8,000 mi“(1) no unusual events. (2) throttle position sensor failed causing poor gas mileage, stalls, and hesitation. (3) replaced tps at a cost of $215. *nm…”
2006-05-16 · Electrical System · 12,800 mi · 💥 crash“ at 9m miles, my 2004 yamaha fz6 began to exhibit the following: 1) after approximately 30 minutes of operation, erratic and prolonged periods of rough idle at 500 rpms instead of the normal 1300 rpms 2) motor would stall during gear changes, even at highway speeds 3) during these times, the smell of gasoline was noticeable. changing the spa…”
2006-03-27 · Fuel System, Other:delivery · 19,840 mi“vehicle: 2004 yamaha fz6 motorcycle, purchase new 12/93. intermittently, the engine surges, cuts out, lugs, stalls/quits at varying times and speeds/riding situations. stopping the bike, turning ignition off and on temporarily corrects problem, but problem always recurs. different weather temperatures and fuel grades have no positive effect. b…”
2006-03-27 · Electrical System · 8,000 mi · 💥 crash“this complaint is in regards to the 2004 yamaha fz6 throttle position sensor. after the motorcycle warms up (approximately 50 miles of riding), it will stall out and/or sputter when the clutch is engaged and/or shifted into neutral. last july it stalled out in the middle of a right hand turn around a red light, resulting in the back tire loosing …”
2006-02-07 · Vehicle Speed Control · 14,000 mi“the motorcycle had progressively worse stalling at stop-lights and stop signs. at times the motorcycle would stutter and stall when trying to initiate the throttle from a stop, and at other times the motorcycle would randomly increase speed while cruising on the highway. the throttle became quite various to the point it was not safe to ride in tr…”
2006-01-09 · Fuel System, Gasoline:delivery · 4,834 mi · 💥 crash“motorcycle's idle rpms change abruptly, to the point of stalling when at slow speeds. this abrupt change was the source of a rear end collision. the bike had been taken in previously to the dealership on multiple occasions but no corrective measures where taken, as the problem could not be reproduced. the symptoms correlate with those of other fz6 …”
2005-09-24 · Electrical System · 6,500 mi“motorcycle randomly will not idle and stalls between shifts. has happened 5 or 6 times. dealer says described symptoms cannot not be diagnosed without fault codes. fault codes are not stored unless certain "idiotic lights" come on during failure. *nm…”
Excerpts of consumer complaints filed with NHTSA, lightly truncated. They are owner statements, not verified findings.