2008 Spartan K3 problems, complaints & recalls
Safety recalls (3)
Engine And Engine Cooling:exhaust System 2016-05-17 · campaign 16V313000 · 2,582 vehicles
Defect: Spartan Motors (Spartan) is recalling certain model year 2007-2015 Spartan K3 and MM motorhome chassis manufactured September 21, 2006, to March 23, 2015. In the affected vehicles, the flexible exhaust tube may tear allowing hot exhaust to blow against other components or materials.
Risk: If hot exhaust gas contacts other components or materials, it can increase the risk of a fire.
Fix: Spartan will notify the motorhome manufacturers that purchased the affected chassis, and Spartan dealers will inspect the alignment of the tubes, correcting them and replacing any that are torn. These repairs will be performed free of charge. The recall began on June 23, 2016. Owners may contact Spartan customer service at 1-517-543-6400. Spartan's number for this recall is 16014. Note: This recall supersedes 15V-554.
Engine And Engine Cooling:cooling System:fan 2015-09-01 · campaign 15V549000 · 1,212 vehicles
Defect: Spartan Motors USA (Spartan) is recalling certain model year 2004-2008 K2, K3 and MM motorhomes manufactured March 17, 2003, to March 15, 2007. In the affected vehicles, the engine cooling fan may separate from the fan drive while the fan is spinning.
Risk: If the engine area is open and the cooling fan is operating and detaches, someone nearby may be injured.
Fix: Spartan will notify owners, and dealers will replace the fan and fan drive system, free of charge. Interim notices were mailed to owners on October 29, 2015. The recall began on October 29, 2015. Owners may contact Spartan customer service at 1-800-582-3454. Spartan's number for this recall is 15014.
Steering 2013-05-08 · campaign 13V182000 · 2,694 vehicles
Defect: Spartan Motors Chassis (Spartan) is recalling certain model year 2006-2011 K2, and K3 and 2006-2010 MM motorhome chassis manufactured July 20, 2005, through December 17, 2010. The steering gear mounting brackets may crack and detach resulting in a loss of steering.
Risk: A loss of steering control may increase the risk of a crash.
Fix: Spartan will notify owners. Starting in mid-June 2013, dealers will install a replacement bracket or a reinforcement to the existing bracket. Until the remedy is available, owners may have their vehicle inspected at any Spartan service center. All repairs will be performed free of charge. Notices were mailed to owners on June 24, 2013. Owners can contact Spartan at 1-855-589-9836.
Service bulletins (4)
Technical service bulletins are repair instructions manufacturers send dealers for known issues. Unlike recalls, the fix is not automatically free — but naming the bulletin at the service desk can save diagnosis time and support goodwill repairs.
Steering 2023-12-11 · TSB23-260-001 · Service Bulletin/Repair Instructions
this service bulletin is about the power steering fluid level sensor could exhibit leaks where sensor seals against power steering reservoir and provides instructions on replacing current power steering level sensor with improved sensor design.
Suspension:multiple Axle:torque Arm 2017-08-18 · 4VZ-E9QSR-09 · Service Bulletin/Repair Instructions
this service bulletin provides instructions on how to apply appropriate torque to rear suspension fasteners to resolve popping noises.
Fuel System, Other:storage:tank Assembly 2015-09-17 · TSB-15-310-002 · Service Bulletin/Repair Instructions
spartan motors: some motor home chassis are experiencing a fuel tank deformity and fuel sender by showing less fuel on fuel gauge than in fuel tank and would need to have fuel sender float arm adjustment. model 2002-15 mm, k3, k2, nvs. *pe
Equipment Adaptive/Mobility 2013-10-03 · TSB-13-500-001 · Service Bulletin/Repair Instructions
spartan: on certain motorhome chassis, the hadley air level system module may not be activated by the interface module and need to change constant battery circuit of module to switch power source (accessory circuit). models 2007-2013 k2, k3. *pe
What owners report
No detailed complaint narratives on file.
Excerpts of consumer complaints filed with NHTSA, lightly truncated. They are owner statements, not verified findings.