2009 Bmw 5 Series problems, complaints & recalls
Most-reported problem areas: Service Brakes, Hydraulic (1) · Fuel System, Gasoline:delivery:fuel Pump (1) · Fuel System, Gasoline (1)
🧭 Reliability snapshot
Compared against other Bmw 5 Series model years — complaint volume vs the model's median year, recalls and severity. How we score →
Safety recalls (4)
Engine And Engine Cooling:exhaust System:emission Control:crankcase (Pcv) 2022-03-02 · campaign 22V119000 · 917,106 vehicles
Defect: BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X5 SA
Risk: An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.
Fix: This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing ow
Engine And Engine Cooling:cooling System:fan 2012-08-10 · campaign 12E029000 · 585 vehicles
Defect: This recall involves aftermarket parts sold by Valeo. Valeo is recalling certain engine cooling fans, part numbers 696121, 696273, and 696275, used as service replacement parts for model year 2008-2011 BMW 1-Series, 2006-2011 BMW 3-Series, 2000-2009 BMW 5-Series, 2004-2005 BMW 6-Series, and 2006-2007 BMW 7-Series vehicles. A metal-oxide semiconductor may overheat due to insufficient screwing of the semiconductor on the aluminum heat sink. This primary failure could cause adjacent components on
Risk: This condition could cause the fan motor to become inoperative, or cause the motor circuit board in the assembly to overheat, potentially leading to a fire in the engine compartment.
Fix: Valeo will notify owners and replace the fans free of charge. The safety recall began on August 22, 2012. This recall is being conducted by Valeo, not by BMW. For further information, owners may contact Valeo at 1-888-718-2536.
Electrical System:12v/24v/48v Battery:cables 2012-03-26 · campaign 12V126000 · 367,682 vehicles
Defect: BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, MODEL YEAR 2004-2010 6-SERIES, MODEL YEAR 2006-2010 M5, AND MODEL YEAR 2007-2010 M6 VEHICLES. THE INSULATED BULKHEAD CONNECTOR FOR THE POSITIVE BATTERY CABLE MAY HAVE BEEN INCORRECTLY ATTACHED TO THE TRUNK FLOOR PANEL, WHICH CAN LEAD TO A LOOSENING OF THE BOLT CONNECTION. AS IT LOOSENS, AN INCREASE IN ELECTRICAL RESISTANCE AT THIS CABLE CONNECTION IS POSSIBLE AND COULD CAUSE THE CABLE CONNECTION TO OVERHEAT.
Risk: OVERHEATING COULD LEAD TO A FIRE, EVEN WHILE THE VEHICLE IS NOT IN USE. AS A PRECAUTION, OWNERS ARE ADVISED TO PARK OUTSIDE UNTIL THE REMEDY HAS BEEN MADE.
Fix: BMW WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND SECURE THE BATTERY BOLT CABLE CONNECTION AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 30, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.
Service Brakes, Hydraulic:power Assist:vacuum 2010-10-01 · campaign 10V446000 · 198,352 vehicles
Defect: BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, 6-SERIES, AND MODEL YEAR 2002-2008 7-SERIES VEHICLES. A CHECK VALVE OF THE BRAKE VACUUM PUMP MAY LEAK A SMALL AMOUNT OF LUBRICATING OIL. OVER TIME THIS COULD RESULT IN CONTAMINATION OF THE BRAKE BOOSTER.
Risk: POWER ASSIST BRAKING PERFORMANCE COULD BE ADVERSELY AFFECTED. IN EXTREME CASES THERE COULD BE A COMPLETE LOSS OF POWER ASSIST BRAKING. AN UNEXPECTED REDUCTION OR LOSS IN POWER BRAKING ASSIST MAY INCREASE THE RISK OF A CRASH.
Fix: BMW WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Service bulletins (76)
Technical service bulletins are repair instructions manufacturers send dealers for known issues. Unlike recalls, the fix is not automatically free — but naming the bulletin at the service desk can save diagnosis time and support goodwill repairs.
Visibility:power Window Devices And Controls 2024-01-16 · B510819 · Service Bulletin/Repair Instructions
the basic conditions for initializing the power windows are not met.
Electrical System 2024-01-11 · B611305 · Service Bulletin/Repair Instructions
the electrical system of bmw vehicles has been subject to an ongoing development process over the last few years. this has led to increased demands being placed on the battery. this document covers important information for the dealer on how to handle ã¢ââdischarged batteryã¢ââ complaints.
Fuel System, Gasoline 2023-12-20 · B160623 · Service Bulletin/Repair Instructions
engine will crank but not start. there is no communication with the integrated fuel module (tfe) whendiagnosing with ista. the following two fault codes will be stored in the dme: 032b43 - low fuel pressure system, electric fuel pump: pressure value too low cda594 - message (- 0x33e) missing, rec
Equipment 2023-11-22 · B653423 · Service Bulletin/Repair Instructions
customers may state that the alarm system (dwa) is not active after locking their unoccupied vehicle. depending on the vehicleã¢ââs equipment and settings, no acoustic or optical confirmation (folding the mirrors/blinking confirmation) is noticeable. additionally, the red anti-theft alarm led in
Vehicle Speed Control 2023-10-19 · B660523 · Service Bulletin/Repair Instructions
various functions of the camera-based driver assistance systems (adcam system) can lead to customer complaints.
Equipment Adaptive/Mobility 2020-10-01 · B611305 · Service Bulletin/Repair Instructions
discharged battery energy diagnosis must be performed: the electrical system of bmw vehicles has been subject to an ongoing development process over the last few years. this has led to increased demands being placed on the battery. this document covers important information for the dealer on how to
Showing the 6 most recent of 76 bulletins. Search all of them free at nhtsa.gov.
What owners report
2016-10-04 · Fuel System, Gasoline:delivery:fuel Pump · 59,500 mi“tl* the contact owns a 2009 bmw 5 series. while driving 75 mph, the vehicle's power seized and the high pressure fuel pump warning indicator illuminated. the vehicle was towed to an independent mechanic, but was not diagnosed or repaired. the manufacturer was not notified of the failure. the approximate failure mileage was 59,500. the vin was not a…”
2014-05-03 · Fuel System, Gasoline · 83,000 mi“the vehicle stalled while i was driving on the freeway. the stall is related to the camshaft sensor not properly working and the fuel system not working properly. i have a 2009 bmw 528i. in april 2014 bmw did a recall related to the camshaft for 2010 - 2014 528 bmw's. i contacted my local dealer and the national bmw dealer to let them know i was h…”
2011-05-23 · Electrical System · 28,000 mi“currently have a 2009 bmw 550i. vehicle has had an ongoing and unidentifiable electrical issue causing the vehicle to often and without initial notice "loose power" and go into a "safety mode" operating at a reduced power by not going above 30mph and/or 3000rpm's. vehicle with often start "bogging" and "shuttering(shaking)" and will often attempt…”
2011-01-06 · Service Brakes, Hydraulic · 15,200 mi · 💥 crash“tl*the contact owns a 2009 bmw 528. the contact stated that while the vehicle was stopped, the brake pedal extended to the floorboard and it moved forward and crashed into a wall. there were no injuries. the contact took the vehicle to the dealer and the manufacturer sent a technician to inspect the vehicle; the technician could not find anything w…”
Excerpts of consumer complaints filed with NHTSA, lightly truncated. They are owner statements, not verified findings.