2009 Volvo Vnm problems, complaints & recalls
Most-reported problem areas: Engine (2) · Trailer Hitches (1)
Safety recalls (2)
Power Train:clutch Assembly 2013-06-26 · campaign 13V268000 · 23,056 vehicles
Defect: Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch. Without a redundant switch, a loss of signal from the brake air pressure switch can prevent the clutch from automatically disengaging when the brake is applied.
Risk: Without a signal to disengage the clutch when the brakes are applied, the distance required to stop the truck may lengthen, increasing the risk of a crash.
Fix: Volvo Trucks will notify owners and dealers will inspect and repair the vehicles if necessary. The recall began on August 26, 2013. Volvo's recall number is RVXX1303. Owners may contact Volvo at 1-336-393-2000.
Equipment:other:labels 2010-10-12 · campaign 10V492000 · 1,926 vehicles
Defect: VOLVO IS RECALLING CERTAIN MODEL YEAR 2008-2011 VHD, VNL, VNM, AS WELL AS 2008-2010 VT VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION." THE TIRE DESCRIPTION MAY BE INCORRECT ON THE VEHICLE'S CERTIFICATION LABEL.
Risk: THE MISINFORMATION ON THESE LABELS COULD LEAD TO A VEHICLE OVERLOADING THAT CAN INCREASE RISK OF A CRASH.
Fix: DEALERS WILL INSPECT AND REPLACE THE LABELS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 25, 2011. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Service bulletins (78)
Technical service bulletins are repair instructions manufacturers send dealers for known issues. Unlike recalls, the fix is not automatically free — but naming the bulletin at the service desk can save diagnosis time and support goodwill repairs.
Parking Brake 2024-02-16 · KC-2347 · Service Bulletin/Repair Instructions
cbr - active "set park brake" message on drivers information display (did)
Power Train 2024-02-16 · KC-202 · Service Bulletin/Repair Instructions
cbr - automated manual transmission ( amt ) flywheel pilot bearing wear on input shaft.
Visibility:defroster/Defogger/Hvac System 2023-12-01 · CBR-2320 202312 · Service Bulletin/Repair Instructions
cbr: 11l engine - air conditioner (a/c) line damaged at bracket - model year 2007 to present.
Electrical System 2023-08-29 · CBR-2120 202308 · Service Bulletin/Repair Instructions
cbr: volvo vhd & vn models - vehicle wil not start, pto active message displayed in cluster, pto light on when pto switch is turned off
Suspension 2023-08-14 · V728-005A 202308 · Service Bulletin/Repair Instructions
tsb: barksdale leveling valve, leak test
Power Train 2023-07-24 · CBR-2112 202307 · Service Bulletin/Repair Instructions
cbr: programming failure - chassis with cummins engine and an allison transmission
Showing the 6 most recent of 78 bulletins. Search all of them free at nhtsa.gov.
What owners report
2019-11-27 · Engine · 738,458 mi“my volvo vnm tractor truck has an oil pressure sensor fault. i was nearly rear ended going down the highway at 60mph because the truck' computer decided it need to stop the truck in the middle of the road. the truck's computer goes into "limp mode". the truck shuts off fuel and does not allow the driver to safely travel down the road. any sensor fa…”
2019-11-27 · Engine · 738,528 mi“my other issue with this truck is. the emissions system is not safe to operate. if the truck's computer cannot detect if there is a plugged dpf/doc filter on the exhaust system the driver cannot manually actuate a regen cycle. the engine's exhaust stream stays plugged and can lead to very dangerous exhaust blockage under the cab of the vehicle as w…”
2010-10-25 · Trailer Hitches · 💥 crash“2009 volvo semi, was westbound when his trailer became disconnected from the tractor and went off the right side of the road and struck the guardrail. *bf (ohio traffic crash report # 10-0372-89)*jb…”
Excerpts of consumer complaints filed with NHTSA, lightly truncated. They are owner statements, not verified findings.