2010 Harley-Davidson Flhtcu problems, complaints & recalls

2023-04-27 · Service Brakes

“i purchased a 2010 harley davidson ultra classic last june. i was riding home last week and went to use the rear break pedal and the brake was rock hard. i scheduled a service to diagnois the issue and found that the abs module can cause the issue. i was notified today that the abs module needs to be replaced and is not covered under the recall for…”

2022-08-25 · Vehicle Speed Control

“on saturday 8/20/22 i was driving to work when i got in the parking lot i lost throttle control it went to limp mode. shut bike off started it back up worked fine. after work i was riding home got bout 2 mile my engine light came on and i lost power to my throttle. it would not rev up. shut bike off for few seconds it ran fine the rest of the way …”

2018-05-25 · Service Brakes, Hydraulic · 21,250 mi

“tl* the contact owns a 2010 harley-davidson flhtcu. while driving 20 mph, the rear brake pedal failed to operate. the contact received notification of nhtsa campaign number: 18v076000 (service brakes, hydraulic). the motorcycle was taken to blue ridge harley-davidson (2002 13th ave dr. se, hickory, nc 28602) where the recall was repaired along with…”

2018-02-20 · Service Brakes · 70,000 mi

“rear brakes would not operate. i was riding and when i went to apply the rear brakes, it was as if i was as if the pedal was froze and no stop at all. the front did work but the rear was completely inoperable. flushing the brake system did not work and i ended up replace the abs brake module to correct the problem. in the owners manual it state…”

2017-10-24 · Service Brakes · 90,000 mi

“abs module failure at speed. hd states that with abs failure, brakes are operable without abs feature. rear pedal has no resistance and front lever is locked. brake operation is normal with switch off, but with bike running or switch in on position, symptoms return.…”

2017-08-26 · Service Brakes · 38,505 mi

“front brake lever locked up, no front brakes. investigated hydraulic system. found that hydraulic control unit was not allowing fluid to flow, thereby causing front brakes not to apply. investigated concern on harley forum that i am a member of, multiple complaints of this concern. i am requesting that harley davidson motor company be investigated…”

2016-07-11 · Service Brakes · 9,000 mi · 💥 crash

“tl* the contact owns a 2010 harley-davidson flhtcu. the contact stated that while driving at 35 mph, the brake pedal and the front brake lever were depressed but the vehicle failed to stop. as a result, the contact crashed into a pavement. the contact sustained back, ribs, left foot, neck and left lung injuries that required medical attention. a po…”

2016-06-09 · Vehicle Speed Control · 26,000 mi

“tl* the contact owns a 2010 harley-davidson flhtcu. while driving 20 mph, the check engine warning indicator illuminated and the acceleration failed. the contact stated that the failure occurred four other times. the vehicle was taken to the dealer where it was diagnosed that the throttle actuator failed. the vehicle was repaired. the manufacturer …”

2016-05-05 · Service Brakes · 24,000 mi

“i was riding my motorcycle and exiting the freeway ramp discovered i had no rear brakes. could not depress the brake pedal, like it was frozen. took it to dealer and they said it was the abs module. if abs fails it should go to non abs brakes (fail safe) instead of no brakes. its only a matter of time before this problem causes loss of life…”

2016-02-13 · Service Brakes · 21,230 mi

“while riding bike and tried to stop on a city street. rear brake pedal went rock hard and would not activate the rear brake caliper. checked rear caliper to see if it was locked up and caliper was fine. caliper pistons moved freely. took bike to dealer and they found the abs distribution block was bad and even though it was full of fluid it would n…”