2010 Toyota Tacoma problems, complaints & recalls
Most-reported problem areas: Suspension (85) · Vehicle Speed Control (32) · Exterior Lighting (22)
🧭 Reliability snapshot
Compared against other Toyota Tacoma model years — complaint volume vs the model's median year, recalls and severity. How we score →
🛣️ Complaints by mileage
191 NHTSA complaints that reported an odometer reading.
Safety recalls (12)
Seats:front Assembly:seat Heater/Cooler 2016-06-02 · campaign 16V396000 · 7,749 vehicles
Defect: Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heat
Risk: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Fix: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Seats:front Assembly:seat Heater/Cooler 2014-11-19 · campaign 14V743000 · 3,233 vehicles
Defect: Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Risk: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Fix: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Suspension:rear:springs:leaf Spring Assembly:leaf 2014-09-29 · campaign 14V604000 · 710,711 vehicles
Defect: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2005-2011 Toyota Tacoma Pre-Runner and 4x4 vehicles manufactured September 14, 2009, to October 11, 2010. In the affected vehicles, one of the leaf springs may fracture due to stress or corrosion. While being driven, the broken leaf could move out of position and contact surrounding components including the fuel tank, possibly puncturing the tank and causing a fuel leak.
Risk: If the fuel tank leaks fuel from being punctured, there is an increased risk of a fire.
Fix: Toyota will notify owners and dealers will install new rear leaf spring assemblies. The recall began on January 29, 2016. Owners may contact Toyota customer service at 1-800-331-4331.
Equipment:other:labels 2014-08-04 · campaign 14V475000 · 20,000 vehicles
Defect: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2014 FJ Cruiser and Tacoma vehicles equipped with accessory wheels and tires installed by Toyota or dealers prior to the vehicle's first sale. The affected vehicles may list incorrect spare tire size and/or cold tire inflation information on the tire placard. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard No. 110, "Tire Selection and Rims for Passenger Cars."
Risk: If the spare tire is inflated to the incorrect pressure provided on the placard, tire failure may occur while it is being driven on, increasing the risk of a crash.
Fix: For the involved vehicles, overlay stickers to correct the tire placard will either be mailed to owners or provided to dealers for placement over the incorrect information on the placard. The recall is expected to begin in September 2014. Owners may contact Toyota customer service at 1-800-331-4331.
Air Bags:frontal:driver Side:inflator Module 2014-04-09 · campaign 14V168000 · 1,486,413 vehicles
Defect: Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
Risk: If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Fix: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is avail
Seat Belts 2013-08-07 · campaign 13V337000 · 342,451 vehicles
Defect: Toyota is recalling certain model year 2005-2010 Tacoma Access Cab vehicles manufactured September 14, 2004, through March 29, 2010; and model year 2011 Tacoma Access Cab vehicles manufactured July 1, 2010, through September 7, 2011. If the access doors are repeatedly and forcefully closed, the screws that attach the seat belt pre-tensioner to the seat belt retractor can loosen over time. If the screws loosen completely, the seat belt pre-tensioner and the retractor spring cover could detach fro
Risk: If the seat belt pre-tensioner detaches from the seat belt assembly, the seat belt pre-tensioner will not perform as designed, increasing the risk of injury in a severe crash.
Fix: Toyota will notify owners, and dealers will inspect the seat belt assemblies. Based on the inspection, the seat belt assembly will be replaced or new pre-tensioner screws will be installed with thread-locking sealant and a retractor spring cover with stopper ribs to prevent loosening of the screws. These services will be provided at no cost to the owner. The recall began during February 2014. Owners may contact Toyota at 1-800-331-4331.
Equipment:other:labels 2013-04-09 · campaign 13V123000 · 7,525 vehicles
Defect: Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicl
Risk: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
Fix: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Seats 2013-01-16 · campaign 13V014000 · 3,235 vehicles
Defect: Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather
Risk: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Fix: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Tires:pressure Monitoring And Regulating Systems 2011-03-04 · campaign 11V148000 · 22,000 vehicles
Defect: TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 FJ CRUISER, LAND CRUISER, TACOMA, SEQUOIA AND TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEM (TPMS)." WHEN FACTORY-INSTALLED WHEELS AND TIRES WERE REPLACED WITH TOYOTA AUTHORIZED ACCESSORY WHEELS AND LT TIRES PRIOR TO FIRST SALE, THE TIRE PRESSURE MONITORING SYSTEMS WERE NOT RE-CALIBRATED CORRECTLY AND THEREFORE DO NOT START ILLUMINATING THE L
Risk: FAILURE TO WARN OF TIRE DEFLATIONS IS A NON-COMPLIANCE WITH FMVSS 138 AND COULD LEAD TO TIRE FAILURE INCREASING THE RISK OF A CRASH.
Fix: FOR THE LAND CRUISER, SEQUOIA, TACOMA AND TUNDRA VEHICLES, THE DEALER WILL RE-CALIBRATE THE TIRE PRESSURE MONITORING SYSTEM ON AFFECTED VEHICLES AND INSTALL AN UPDATED TIRE AND LOADING INFORMATION LABEL AT NO CHARGE. FOR THE FJ CRUISER VEHICLES, THE TPMS CANNOT BE RESET SO THE ELECTRONIC CONTROL UNIT (ECU) FOR THE TPMS WILL BE REPLACED. TOYOTA IS CURRENTLY DEVELOPING THE REMEDY ECU. IF AN OWNER IS NOT CERTAIN WHETHER HIS OR HER VEHICLE IS EQUIPPED WITH THESE ACCESSORIES, PLEASE CONTACT ANY TO
Power Train:driveline:driveshaft 2010-02-18 · campaign 10V042000 · 8,000 vehicles
Defect: TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA TACOMA PICKUP TRUCKS. THE PROPELLER SHAFT MAY DEVELOP CRACKS DURING THE MANUFACTURING PROCESS. OVER TIME, THE CRACKS MAY EVENTUALLY LEAD TO THE SEPARATION OF THE PROPELLER SHAFT.
Risk: THIS MAY RESULT IN A LOSS OF VEHICLE CONTROL INCREASING THE RISK OF A CRASH.
Fix: DEALERS WILL INSPECT AND REPLACE THE FRONT PROPELLER SHAFT ON AFFECTED VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Equipment:other:labels 2010-02-03 · campaign 10V035000 · 271,417 vehicles
Defect: GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Risk: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Fix: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Equipment:other:labels 2010-02-03 · campaign 10V036000 · 153,418 vehicles
Defect: SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Risk: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Fix: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Service bulletins (365)
Technical service bulletins are repair instructions manufacturers send dealers for known issues. Unlike recalls, the fix is not automatically free — but naming the bulletin at the service desk can save diagnosis time and support goodwill repairs.
Unknown Or Other 2026-01-07 · T-SB-0055-24 Rev2 · Service Bulletin/Repair Instructions
some 2005 – 2026 toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. follow the procedures in this bulletin to remediate the odor and address this condition. the purpose of this service bulletin is to provide general guidelines and procedures
Structure:body 2024-12-06 · T-SB-0039-24 Rev2 · Service Bulletin/Repair Instructions
the condition known as acid rain is caused by airborne chemicals or particles in the atmosphere, which mix with rainwater, nighttime dew, or high humidity to form acidic compounds. if these contaminants settle and remain on a painted vehicle surface, especially the horizonal areas of the hood, roof,
Structure:body 2024-12-06 · T-SB-0038-24 Rev2 · Service Bulletin/Repair Instructions
to prevent brake rotor rust from forming during transportation and storage, wheel film will be used instead of a cardboard type of anti-rust cover. the purpose of the wheel film is to shield the disc brake rotor from weather elements and initial rust before the vehicle is delivered to the customer.
Structure:body 2024-12-06 · T-SB-0035-24 Rev2 · Service Bulletin/Repair Instructions
acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical impurities in the atmosphere. if these acidic compounds settle on an exposed vehicle, especially the horizontal areas such as the hood, roof, and decklid, significant damage to the painted surfa
Structure:body 2024-12-05 · T-SB-0061-23 Rev2 · Service Bulletin/Repair Instructions
toyota vehicles are currently protected with rapgardtm protective film designed to protect the horizontal painted surfaces. this material protects from acid rain, environmental fallout, and rail contamination. follow the removal procedure in this bulletin to remove the rapgardtm protective film wi
Structure:body 2024-12-03 · T-SB-0062-23 Rev2 · Service Bulletin/Repair Instructions
vehicles may occasionally be subjected to contamination by airborne iron particles shed from railroad tracks, train wheels, exposure to heavy machinery facilities, grinding, welding, etc. this type of contamination can be identified by the presence of small, red or brown particles on the paint surfa
Showing the 6 most recent of 365 bulletins. Search all of them free at nhtsa.gov.
What owners report
2026-09-22 · Unknown Or Other“the vehicle's structure (frame) is failing. a recall for corrosion susceptibility was disseminated for the make and model of my vehicle. a coating was applied to the frame, and i was then told by malloy toyota that rust will now not become a problem for the frame, as "it's been properly treated according to toyota's standards following the recall.…”
2026-08-24 · Structure · 49,000 mi“the contact owns a 2010 toyota tacoma. the contact stated that while the vehicle was in for inspection, the mechanic informed the contact that the entire subframe was rusted. the contact was advised that the vehicle was unsafe to drive due to the rust on the subframe. the cause of the failure was not yet determined. the vehicle was not repaired. th…”
2026-08-22 · Structure:body“took 2010 toyota tacoma to independent garage for a problem with tire pressure sensor. the sensor was fixed, however employee of the garage made us aware that there was substantial rust/corrosion on the tacoma frame. have made 2 calls this last week to the toyota customer relations/brand engagement specialist. gave the representative all informati…”
2026-08-03 · Unknown Or Other“the passenger side lower a arm frame mount broke, due to frame rust. the truck has been taken to toyota, they had the truck for about 6 weeks and have refused to fix the safety issue.this year model had a recall on the frame, it was taken in for the recall, but the recall has failed. when the lower a arm frame mount broke, i just happened to be in …”
2026-06-22 · Structure · 100,000 mi“the contact owns a 2010 toyota tacoma. the contact stated that while the vehicle was with an independent mechanic for a scheduled service, the contact was informed that the frame underneath the engine was rusted. the contact was advised to take the vehicle to the dealer. the vehicle was taken to the dealer, where the contact was informed that an un…”
2026-04-07 · Suspension“2010 toyota tacoma with 91k miles have frame corrosion and now has holes. i contacted toyota motor sales usa, inc. and informed them why i never received a recalled and they said it was mailed may 2019 and expired in 2022-there’s nothing they can do and if i went to the dealership for my inspections they would of known of the recall instead of goin…”
2026-02-19 · Air Bags · 💥 crash“our son hit a guardrail and the airbags didn't deploy. accident and failure was reported to insurance company…”
2026-01-29 · Structure:body“i am the original owner of a 2010 toyota tacoma trd sport, 4 door, 4wd, with a 6' bed, vin # [xxx] , with 215902 miles. during the replacement of the leaf springs on 1/27/26, under recall #14v-604, i was informed by the toyota dealership that installed the leaf springs that there was extensive corrosion on various points on the frame to the point w…”
2026-01-14 · Unknown Or Other“chassis/frame was recalled on warranty that toyota did not inform me of and they refused to do anything about it. they said two regular mail letters were sent out to me. i have never received them. the framing of my vehicle is so bad that an accident was waiting to happen when i took my vehicle foreign oil exchange. i asked them to look at the muff…”
2025-10-16 · Unknown Or Other“my 2010 toyota tacoma frame is rusted and deteriorated. this has been confirmed by my local toyota dealership (ira toyota of saco , me) the vehicle has approximately 130,000 miles and is in otherwise good working order. i do not expect a 15 year old toyota to have a rusted frame, which has become entirely unsafe. indeed, the toyota dealership ref…”
Excerpts of consumer complaints filed with NHTSA, lightly truncated. They are owner statements, not verified findings.