2011 Tiffin Allegro Bus problems, complaints & recalls
Most-reported problem areas: Structure (1)
Safety recalls (4)
Visibility:windshield Wiper/Washer 2016-07-13 · campaign 16V532000 · 10,351 vehicles
Defect: Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2007-2011 Allegro, Allegro Bus, Phaeton, and Zephyr motorhomes, 2007-2010 Allegro Bay motorhomes, and 2010-2011 Allegro Breeze motorhomes. The windshield wiper arms on the affected vehicles may break off.
Risk: If the windshield wiper arms break, the driver's visibility may be reduced, increasing the risk of a crash.
Fix: Tiffin will notify owners, and dealers will replace the wiper blade arms, free of charge. The recall began on August 19, 2016. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIFF-100.
Structure:frame And Members:underbody Shields 2012-10-31 · campaign 12V526000 · 847 vehicles
Defect: Tiffin Motorhomes is recalling certain model year 2010-2013 Allegro Bus motorcoaches, manufactured from March 2010, through September 2012 and equipped with a Cummins EPA 2010 ISL engine. Insufficient shielding between the exhaust pipe and floor may cause possible overheating of the floor above the engine compartment.
Risk: If the exhaust pipe in the engine compartment were to fail, the escaping exhaust gases could make the floor area above the engine extremely hot, increasing the risk of personal injury or possibly resulting in a fire.
Fix: Tiffin Motorhomes will notify owners, and dealers will install a heat shield, free of charge. The safety recall began on November 14, 2012. Owners may contact Tiffin at 1-256-356-8661.
Engine And Engine Cooling 2011-09-23 · campaign 11V485000 · 179 vehicles
Defect: TIFFIN MOTORHOMES IS RECALLING CERTAIN MODEL YEAR 2011 ALLEGRO BUS AND PHAETON RECREATIONAL VEHICLES BUILT ON THE POWERGLIDE CHASSIS EQUIPPED WITH A CUMMINS ISX OR ISL DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAU
Risk: IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.
Fix: TIFFIN MOTORHOMES IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR TIFFIN MOTORHOMES AT 1-256-356-8661.
Equipment 2010-10-25 · campaign 10V512000 · 62 vehicles
Defect: TIFFIN MOTORHOMES IS RECALLING CERTAIN MODEL YEAR 2011 ALLEGRO, ALLEGRO BUS, AND PHAETON RVS EQUIPPED WITH ATWOOD 35 SERIES RANGE OVENS. A POTENTIAL EXISTS FOR A SMALL FRACTURE WITHIN THE LINE DELIVERING GAS TO THE OVEN CAVITY BURNER. SUCH A FRACTURE MAY CAUSE PROPANE GAS TO LEAK FROM THE LINE.
Risk: A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE AND/OR EXPLOSION CAUSING PROPERTY DAMAGE AND/OR PERSONAL INJURY.
Fix: TIFFIN IS WORKING WITH ATWOOD AND WILL REPLACE OR REPAIR THE STOVES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 28, 2010. OWNERS MAY CONTACT ATWOOD AT 1-574-266-4749 OR TIFFIN 1-256-356-8661.
Service bulletins (6)
Technical service bulletins are repair instructions manufacturers send dealers for known issues. Unlike recalls, the fix is not automatically free — but naming the bulletin at the service desk can save diagnosis time and support goodwill repairs.
Equipment:other:owners/Service/Other Manual 2017-11-10 · Letter to dealer · Service Bulletin/Repair Instructions
this was a letter to our dealers we sent out when we first heard of the kidde fire extinguisher recall, even though it was still unofficial. we knew our coaches on the dealers' lots contained kidde and could not be sold unreplaced.
Equipment:appliance:air Conditioner 2015-11-24 · SB-36 · Service Bulletin/Repair Instructions
tiffin motorhomes: tsb contains notification of owner letter. select document search button below. two screws was not installed on the air condition units on the roof. *ta updated 11/24/15. *pe
Electrical System:wiring: Rear Compartment/Trunk 2015-07-16 · 16AWG · Service Bulletin/Repair Instructions
rv: instructions on how to install the charge solenoid wiring in a rv or vehicle. *ta
Equipment 2015-06-26 · C85-C86AC · Service Bulletin/Repair Instructions
tiffin motorhomes: tsb contains notification of owner letter. select document search button below. all tiffin motorhomes will be installing 2 back screws of the c85 and c86 a/c's to the roof of all tiffin motorhomes. *ta.
Engine And Engine Cooling:exhaust System:manifold/Header/Muffler/Tail Pipe 2014-05-23 · WI-268 · Service Bulletin/Repair Instructions
tiffin motorhomes: exhaust tip and pipes for muffler on bus models needs to be installed. *ta
Equipment:recreational Vehicle/Trailer 2013-03-12 · WI-196 · Service Bulletin/Repair Instructions
tiffin motorhomes: tsb contains notification of owner letter. select document search button below. some tiffin motorhomes need driver/passenger seatbelts tightened on the mounting brackets located on the driver/passenger sidewall. *ta
What owners report
2023-05-03 · Structure · 48,000 mi“the contact owns a 2011 tiffin allegro bus. the contact initially received notification of nhtsa campaign number: 12v526000 (structure) and the rv was taken to a rv dealer and serviced. recently, the contact took the rv to an independent mechanic for routine maintenance check and was informed that the part used to repair the exhaust shield, had rub…”
Excerpts of consumer complaints filed with NHTSA, lightly truncated. They are owner statements, not verified findings.