2015 Micro Bird Mb Ii School Bus problems, complaints & recalls

Defect: Corp. Micro Bird, Inc. (Micro Bird) is recalling certain 2003-2026 MB II, 2006-2026 G5, and 2015-2026 T-Series school buses. An installation error may prevent the wheelchair tie-downs from locking, leaving the wheelchair improperly secured.

Risk: An unsecured wheelchair can move during transit or a crash, increasing the risk of injury.

Fix: Dealers will inspect and secure the anchor screw cap as necessary, free of charge. Owner notification letters were mailed April 28, 2026. Owners can contact Micro Bird Customer Service at 819-477-2012. Micro Bird's number for this recall is 26-120-AUS.

Defect: Corp. Micro Bird, Inc. (Micro Bird) is recalling certain 2008-2025 G5, 2008-2024 MBII, and 2015-2024 T-Series school buses. The rear emergency door exterior handle may unexpectedly break under applied force.

Risk: In the event of an emergency, a broken door handle can prevent or delay emergency responders from entering the bus, increasing the risk of injury.

Fix: Dealers will replace the rear emergency door exterior handle, free of charge. Owner notification letters were mailed August 15, 2024. Owners may contact Micro Bird customer service at 1-819-477-2012. Micro Bird's number for this recall is 24-109-EUS.

Defect: Corp. Micro Bird, Inc. (Micro) is recalling certain 2012-2023 G5, 2012-2023 MBII and 2015-2022 T-Series school buses. The power cable that provides electricity to the air conditioning control board may have a loose connection to the power stud on the board.

Risk: A loose power cable connection may cause the control board to overheat and melt, increasing the risk of a fire.

Fix: Dealers will redirect the power cable and secure the power cable connect as necessary, free of charge. Owner notification letters were mailed on March 2, 2023. Owners may contact Micro Bird customer service at 1-819-477-2012. Micro Bird's number for this recall is 22-096-VUS.

Defect: Corp. Micro Bird, Inc. (Micro Bird) is recalling certain 2006-2021 MBII and G5 school buses. An inactive electrical harness that is secured in an opening in the B-pillar may become damaged from sharp edges inside the opening.

Risk: A damaged electrical harness may short circuit, increasing the risk of a fire.

Fix: Dealers will secure the electrical harness and remove the fuse linked to the main cable, free of charge. Owner notification letters were mailed on June 20, 2022. Owners may contact Micro Bird's customer service at 1-819-477-2012. Micro Bird's number for this recall is 22-092-HUC.

Defect: Corp. Micro Bird, Inc. (Micro Bird) is recalling certain 2006-2021 MBII and G5 transit buses. An inactive electrical harness that is secured in an opening in the B-pillar may become damaged from sharp edges inside the opening.

Risk: A damaged electrical harness may short circuit, increasing the risk of a fire.

Fix: Dealers will secure the electrical harness and remove the fuse linked to the main cable, free of charge. Owner notification letters were mailed on June 20, 2022. Owners may contact Micro Bird's customer service at 1-819-477-2012. Micro Bird's number for this recall is 22-092-HUS.

Defect: Corp. Micro Bird, Inc. (Micro Bird) is recalling certain 2003-2022 MBII, T-Series, and G5 school buses. The emergency release handle on the service door may bind, not allowing the door panels to open.

Risk: The service door may not open, preventing evacuation of the vehicle in case of emergency, and increasing the risk of injury.

Fix: Dealers will provide instructions on how to correctly adjust the service door, free of charge. Owner notification letters were mailed on September 8, 2021. Owners may contact Micro Bird customer service at 1-819-477-2012. Micro Bird's number for this recall is 21-087-DUS.

Defect: Corp. Micro Bird Inc. (Micro Bird) is recalling certain 2004-2021 T-Series, G5, and MBII school buses. The emergency door retaining device may fail to keep the door in an open position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 217, "Bus Emergency Exits and Window Retention and Release."

Risk: If the emergency door won't stay open during an evacuation it can increase the risk of injury.

Fix: Micro Bird will notify owners, and dealers will install a kit to repair the emergency door retaining device, free of charge. The recall April 24, 2020. Owners may contact Micro Bird customer service at 1-819-477-2012. Micro Bird's number for this recall is 20-084-RUS.

Defect: Corp. Micro Bird Inc. (Micro Bird) is recalling certain 2012-2018 Micro Bird G5, MBII, and T-Series school buses, equipped with certain S-Series and K-Series Titanium Wheelchair Lifts, models K200, K201, K550, K551, S200, S2201, S550 and S551. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FM

Risk: If the wheelchair lift platform stops above the vehicle floor, the wheelchair user can tip inwards toward the vehicle when exiting the lift, increasing their risk of injury.

Fix: Micro Bird will notify owners, and Ricon dealers will replace the injection molded cam with a new aluminum machined cam. The recall is expected to begin October 22, 2018. Owners may contact Micro Bird customer service at 1-819-477-2012. Micro Bird's number for this recall is 18-077-RUS.

Defect: Corp. Micro Bird Inc. (Micro Bird) is recalling certain 2015-2018 Micro Bird G5, MB II, and T-Series school buses. During manufacturing, the seat belt anchorage plate may not have been correctly attached to the wall, limiting the capacity of the shoulder belt to restrain a passenger in the event of a crash.

Risk: If the belt anchorage plate detaches from the wall and cannot properly restrain a passenger it can increase the risk of injury.

Fix: Micro Bird Corporation will provide inspection and field modification instructions, and the material kit required to complete this recall repair, free of charge. The recall began September 26, 2018. Owners may contact Micro Bird customer service at 1-819-477-2012. Micro Bird's number for this recall is 18-075-CUS.

Defect: Corp. Micro Bird Inc. (Micro Bird) is recalling certain 2011-2018 Micro Bird G5, MB-II, and T-series school buses, equipped with CE White/HSM SB11-30" series, standard, unbelted, school bus seats, or SB11-30" series school bus seats with lap belts only. The foam in the knee impact area of the lower seat back may not absorb enough impact in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 222, "School Bus

Risk: If the seat foam does not absorb enough impact energy, it can increase the risk of injury in the event of a crash.

Fix: Micro Bird will notify owners and dealers will insert an additional piece of expanded polystyrene (EPS) foam into the seatback, free of charge. Micro Bird issued interim notifications to owners on September 12, 2018. The recall began December 7, 2018. Owners may contact Micro Bird customer service at 1-819-477-2012. Micro Bird's number for this recall is 18-074-SUS.

Defect: Corp. Micro Bird Inc. (Micro Bird) is recalling certain 2012-2017 MB II school buses. In the event of a rollover, the roof strength may be insufficient to prevent the roof from crushing. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 220, "School Bus Rollover Protection."

Risk: In the event of a rollover, if the school bus roof crushes, the occupants have an increased risk of injury.

Fix: Micro Bird will notify owners, and dealers will modify the buses to prevent the roof from crushing, free of charge. The recall began on June 5, 2017. Owners may contact Micro Bird customer service at 1-819-477-2012. Micro Bird's number for this recall is 17-070-SUS. Note: This recall supersedes recall 15V-683.

Defect: Corp. Micro Bird Inc. (Micro Bird) is recalling certain model year 2015 MBII and G5 school buses manufactured between May 1, 2015, and December 18, 2015, equipped with Transpec stop arms, part numbers T6000-, T6100-, and T7000-. The STOP decal may peel off the plastic blade of the stop arm. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 131, "School Bus Pedestrian Safety Devices."

Risk: Absence of the reflective decal would reduce visibility to other drivers, increasing the risk of a crash.

Fix: Micro Bird will notify owners and recall repair kits will be available free of charge. The recall began on January 20, 2016. Owners may contact Micro Bird customer service at 1-819-477-2012.

Defect: Corp. Micro Bird Inc. (Micro Bird) is recalling certain model year 2014-2016 MBII and G5 school buses manufactured May 21, 2014, to November 24, 2015. The affected vehicles may have a camber caster kit bolt that was insufficiently torqued, causing the bolt to come loose.

Risk: An insufficiently torqued bolt may become loose and fall out causing vehicle misalignment. Loss of vehicle control is possible, increasing the risk of a crash.

Fix: Micro Bird will notify owners, and dealers will correct the torque, free of charge. The recall began on January 18, 2016. Owners may contact Micro Bird customer service at 1-819-477-2012. Micro Bird's number for this recall is 10-065-AUS.