2019 Wabash National Van problems, complaints & recalls
Most-reported problem areas: Wheels (1)
Safety recalls (4)
Structure:body 2023-09-20 · campaign 23V646000 · 3,711 vehicles
Defect: Wabash National Corporation (Wabash) is recalling certain 2009-2024 dry van trailers equipped with a rail-style lift gate. Please see the recall report for a complete list of models. The location of the rear impact guard is too far forward from the rear of the trailer, reducing impact protection. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 224, "Rear Impact Protection."
Risk: In the event of a rear impact crash, the rear impact guard may not sufficiently protect light duty vehicles, increasing the risk of injury.
Fix: Dealers will add an extension to the rear impact guard, free of charge. Owner notification letters were mailed December 4, 2023. Owners may contact Wabash customer service at 1-765-771-5404. Wabash's number for this recall is B23015.
Fuel System, Gasoline:storage:tank Assembly:mounting 2021-07-30 · campaign 21V588000 · 352 vehicles
Defect: Wabash National Corporation (Wabash) is recalling certain 2018-2022 Van Trailers. The fuel tank brackets may detach.
Risk: Detached fuel tank brackets could allow the fuel tank to separate from the vehicle, increasing the risk of a crash or injury.
Fix: Dealers will add an aluminum plate and 4 fasteners to each bracket, free of charge. Owner notification letters were mailed on August 18, 2021. Owners may contact Wabash customer service at 1-765-771-5404. Wabash's number for this recall is B21012.
Equipment 2020-09-10 · campaign 20V551000 · 218 vehicles
Defect: Wabash National Corporation (Wabash) is recalling certain 2019-2021 Van trailers manufactured with flat bottom floors that are equipped with aerodynamic skirts. The aerodynamic skirts attached to the van trailers may come loose.
Risk: If the aerodynamic skirt detaches while the trailer is moving it may increase the risk of a crash or injury.
Fix: Wabash has notified owners, and dealers will rework the safety tether assembly to keep the skirt attached, free of charge. The recall began September 21, 2020. Owners may contact Wabash's customer service at 765-771-5404. Wabash's number for this recall is B20012.
Structure:body 2018-11-15 · campaign 18V808000 · 5,194 vehicles
Defect: Wabash National Corporation (Wabash) is recalling certain 2014-2019 Wabash National Van trailers equipped with limb deflectors. The limb deflectors installed on the upper rear corner of the trailers may detach while moving.
Risk: If the limb deflectors detach, it can increase the risk of a crash.
Fix: Wabash will notify owners, and dealers will remove the limb deflectors, free of charge. The recall began November 30, 2018. Owners may contact Wabash customer service at 1-765-771-5404. Wabash's number for this recall is LEG201803.
Service bulletins (3)
Technical service bulletins are repair instructions manufacturers send dealers for known issues. Unlike recalls, the fix is not automatically free — but naming the bulletin at the service desk can save diagnosis time and support goodwill repairs.
Engine And Engine Cooling 2020-08-17 · B20011 · Service Bulletin/Repair Instructions
it has been determined that the exhaust manifold of the carrier tru may cause yellowing and sometimes non-structural cracking to the the exterior nose wall
Equipment Adaptive/Mobility 2020-06-09 · B20008 · Service Bulletin/Repair Instructions
due to a customer complaint of a cracked spring post, an internal quality inspection found that a galvanic barrier had not been installed between the galvanized aeroskirt spring posts and the aluminum mounting plates on the bottom of the trailer. over an extended period of time, this can lead to g
Equipment 2020-05-27 · B20008 · Service Bulletin/Repair Instructions
due to a customer complaint of a cracked spring post, an internal quality inspection found that a galvanic barrier had not been installed between the galvanized aeroskirt spring posts and the aluminum mounting plates on the bottom of the trailer. over an extended period of time, this can lead to gal
What owners report
2019-06-21 · Wheels · 60,000 mi“tl* the contact owns a 2019 wabash national van. the contact stated that the vehicle had an alignment failure. while driving and pulling a trailer, the vehicle would go six inches over to the right of the white line on the road. the vehicle was taken to tec equipment stockton (located at 2050 e louise ave, lathrop, ca 95330, (209) 858-4110) where a…”
Excerpts of consumer complaints filed with NHTSA, lightly truncated. They are owner statements, not verified findings.