2022 Thor Motor Coach Sequence problems, complaints & recalls
Most-reported problem areas: Steering (1) · Equipment:recreational Vehicle/Trailer (1) · Electrical System:alternator/Generator/Regulator (1)
Safety recalls (3)
Structure:critical Fasteners 2025-11-17 · campaign 25V791000 · 4,763 vehicles
Defect: Thor Motor Coach (TMC) is recalling certain 2023-2024 Twist, Dazzle, 2023 Tranquility, Sanctuary, 2022-2024 Tellaro, Sequence, and 2024 Freedom Elite Van recreational vehicles. The solar panel mounting brackets may become loose or break allowing the solar panel to detach.
Risk: A detached solar can become a road hazard for other vehicles, increasing the risk of a crash.
Fix: Dealers will inspect and install missing washers, as necessary, free of charge. Owner notification letters were mailed January 12, 2026. Another notice will be sent once the remedy becomes available. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000336.
Equipment:recreational Vehicle/Trailer:lpg Systems:lines And Fittings 2022-05-05 · campaign 22V300000 · 3,374 vehicles
Defect: Thor Motor Coach (TMC) is recalling certain 2022 Scope, Tellaro, Sanctuary, Delano, Sequence, Tranquility, Rize, Synergy, Quantum, Magnitude, Geneva, Compass, Chateau, Four Winds, and 2022-2023 Tiburon, and Gemini vehicles. The quick disconnect fittings in the LP gas system may be cracked, causing a gas leak.
Risk: A gas leak in the presence of an ignition source can increase the risk of a fire.
Fix: Dealers will replace the quick disconnect fittings, free of charge. Owner notification letters were mailed June 27, 2022. Owners may contact TMC customer service at 1-877-855-2867.
Equipment:recreational Vehicle/Trailer 2021-05-26 · campaign 21V396000 · 53 vehicles
Defect: Thor Motor Coach (TMC) is recalling certain 2022 Rize, Scope, Sequence, and Tellaro vehicles. The Flex-190 Solar Panel junction box may short.
Risk: An electrical short can cause the junction box to overheat, increasing the risk of a fire.
Fix: Dealers will install a new solar panel and junction box, free of charge. Owner notification letters were mailed July 22, 2021. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000226.
Service bulletins (1)
Technical service bulletins are repair instructions manufacturers send dealers for known issues. Unlike recalls, the fix is not automatically free — but naming the bulletin at the service desk can save diagnosis time and support goodwill repairs.
Equipment 2022-08-29 · TSB 22-11 · Service Bulletin/Repair Instructions
timer module used with relion batteries is not functioning properly which could overload the batteries and cause them to temporarily shut down. if the unit is not equipped with relion batteries, no repair is needed.
What owners report
2026-09-29 · Steering“alternator belt issues. chassis belt broke 2 times . house, under hood generator alternator belt broke one. first time there was no warning. but resulted in lose of power steering and coolant. cut into the coolant hose. a clean break break, not shredded. second time on start there no warning until the engine over heated and smoke poured from the en…”
2024-11-06 · Equipment:recreational Vehicle/Trailer“thor sequences rv: the roof top solar that was installed by thor motorcoach flew off of the rv roof while i was driving on [xxx] in downtown columbus, ohio. i thought something fell out of a cabinet when i heard a thud. i exited [xxx] on [xxx], and a central ohio transit authority van driver told something flew off the roof of the rv. i parked and…”
2023-07-27 · Unknown Or Other“cabinets are falling off ceiling. screws falling out. could ask on passenger side bed.…”
2022-08-10 · Electrical System:alternator/Generator/Regulator · 10,500 mi“the contact owns a 2022 thor motor coach sequence 20k rv. the contact stated that the skid plate to protect the alternator had the incorrect oem bolt size and was also missing bolts to secure the alternator. the dealer was made aware of the failure; however, the contact realigned the skid plate and replaced the bolts with the correct size by himsel…”
Excerpts of consumer complaints filed with NHTSA, lightly truncated. They are owner statements, not verified findings.