2022 Thor Motor Coach Windsport problems, complaints & recalls
Most-reported problem areas: Visibility/Wiper (1) · Structure (1)
Safety recalls (1)
Structure:body:step/Ladder 2022-02-10 · campaign 22V076000 · 148 vehicles
Defect: Thor Motor Coach (TMC) is recalling certain 2022 ACE, Freedom Traveler, Hurricane, and Windsport motorhomes. The rear ladder may have been installed on the wrong side of the motorhome.
Risk: An incorrectly installed ladder may break while in use, increasing the risk of injury.
Fix: Dealers will inspect the location of the rear ladder, and reinforce or relocate the ladder as needed, free of charge. Owner notification letters were mailed March 24, 2022. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000255.
Service bulletins (4)
Technical service bulletins are repair instructions manufacturers send dealers for known issues. Unlike recalls, the fix is not automatically free — but naming the bulletin at the service desk can save diagnosis time and support goodwill repairs.
Structure 2022-09-22 · TSB 22-12 · Service Bulletin/Repair Instructions
wood stiles are delaminating due to the vendor changing the glue used for the wrapped stiles.
Electrical System 2021-06-09 · TSB 21-04 · Service Bulletin/Repair Instructions
during production, the fm antenna was not included on the new 32â connex entertainment tvs (tmc part # 484102). these tvs have a built in radio tuner, and the reception will be poor without the antenna
Power Train:automatic Transmission:internal:bearings/Bushings 2021-05-19 · RC000219SADealer · Service Bulletin/Repair Instructions
on your vehicle, the rear axle may contain an inadequate volume of lubricating oil. an inadequate volume of rear axle lubricant may result in rear wheel bearing damage potentially leading to bearing seizure. bearing seizure may lead to rear axle or driveshaft failure. a rear axle or driveshaft fai
Engine And Engine Cooling 2021-02-18 · RC000212SAOwner · Service Bulletin/Repair Instructions
on your vehicle, it may be possible that the engine cover insulation does not fully extend to the perimeter of the factory engine cover. in addition, vehicles built on a ford chassis may have higher engine compartment temperatures during certain idle conditions. this may result in elevated tempera
What owners report
2026-06-09 · Unknown Or Other“i’m concerned about the bbq propane compartment getting hairline cracks and the brass shut off valve that’s made of brass and dropping down to the road and getting road rash till it grinds through the shut off valve. i just read on a thor facebook forum that this happened to a 2016 thor windsport 34p. i have the pictures he posted. i asked ai gemi…”
2024-11-25 · Visibility/Wiper“while driving on a crowded freeway a wooden structure fell from the ceiling of my motorhome and landed on the dashboard inches from my steering wheel. if it had hit my steering wheel or my hands, i would have been involved in a multiple vehicle collision. thank god, i was able to safely pull over to the shoulder to check for damage. the beam was to…”
2024-10-21 · Structure · 14,000 mi“the contact owns a 2022 thor motor coach windsport rv built on a 2020 ford f-53 chassis. the contact stated that while driving at 65 mph, a wooden beam used to deflect airflow from the outer venting fell from the ceiling of the rv. the heavy beam fell inches away from the contact's hands that were on the steering wheel. the contact pulled over afte…”
2024-05-27 · Unknown Or Other“the propane heater on our motorhome has been cycling on the high limit switch since new. this is due to insufficient airflow across the heat exchanger. it is also the source of intermittent carbon monoxide alarms being activated. we have had this unsuccessfully repaired under warranty. the cycling continues. if other units of this model series were…”
2024-03-09 · Unknown Or Other“main propane heater in my thor windsport 29m motorhome was coming on and goings on off before the desired temperature was reached. i realized it was cycling on the high limit switch, which is.generally caused by insufficient air flow over the heat exchanger. took it in for warranty service which identified the cause as a kinked heater hose, which …”
Excerpts of consumer complaints filed with NHTSA, lightly truncated. They are owner statements, not verified findings.