2022 Tiffin Allegro problems, complaints & recalls
Most-reported problem areas: Structure:body (1)
Safety recalls (5)
Equipment:recreational Vehicle/Trailer:lpg Systems 2022-07-20 · campaign 22V511000 · 1,323 vehicles
Defect: Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2021-2023 Allegro, Red 340, 2021-2022 Phaeton, Breeze, Allegro Red 360, and 2022 Bay motorhomes. The output line on the LPG tanks may not connect properly to the service valve, which can cause a propane leak.
Risk: A propane leak in the presence of an ignition source can increase the risk of a fire.
Fix: Dealers will inspect and replace the service valves, as necessary, free of charge. Owner notification letters were mailed September 18, 2022. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-124.
Equipment:recreational Vehicle/Trailer 2022-04-22 · campaign 22V273000 · 679 vehicles
Defect: Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2021-2022 Allegro and 2022 Allegro Bay motorhomes. The slide-room may extend out 6 to 8 inches while parked or possibly while moving, due to defective seals in the hydraulic cylinders.
Risk: A slide-room that were to extend unintentionally during transit can increase the risk of a crash.
Fix: Dealers will replace the hydraulic cylinders, as necessary, free of charge. Owner notification letters were mailed June 1, 2022. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-122.
Electrical System 2022-02-08 · campaign 22V068000 · 3,708 vehicles
Defect: Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2022 Allegro and Allegro Breeze motorhomes. The buss bar may be improperly secured, which can cause electrical components in the DC Distribution Panel to overheat.
Risk: Overheated electrical components can melt and increase the risk of a fire.
Fix: Dealers will replace the buss bar with a cable, free of charge. Owner notification letters were mailed March 18, 2022. Owners may contact Tiffin customer service at 1-256-356-0261. Tiffin's number for this recall is TIF-120.
Seat Belts:rear/Other:anchorage 2021-11-05 · campaign 21V680000 · 10,409 vehicles
Defect: Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2022 Allegro Breeze, Allegro Red, Allegro, Allegro Bus, Phaeton, and 2018-2021 Zephyr recreational vehicles. The sofa seat belts may not have been installed correctly, which could result in unsecured passengers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."
Risk: Unsecured passengers have an increased risk of injury in the event of a crash.
Fix: Dealers will inspect and repair the seat belts as necessary, free of charge. Owner notification letters were mailed October 29, 2021. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-118.
Fuel System, Diesel:delivery:hoses, Lines/Piping, And Fittings 2021-07-20 · campaign 21V545000 · 330 vehicles
Defect: Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2021-2022 Allegro Bus and Phaeton motorhomes, equipped with certain Cummins L9 diesel engines. A fuel leak may occur from the fuel hose between the fuel pump and remote filter head.
Risk: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Fix: Dealers will replace the fuel hoses, free of charge. Owner notification letters were mailed September 10, 2021. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-117.
Service bulletins (4)
Technical service bulletins are repair instructions manufacturers send dealers for known issues. Unlike recalls, the fix is not automatically free — but naming the bulletin at the service desk can save diagnosis time and support goodwill repairs.
Exterior Lighting 2025-06-09 · MCD-009 · Other
stopped using the lights we had been using due to expense. replaced with these, but these new lights have to be wired in instead of just clicking in. these are the instructions to wire in.
Equipment:other:owners/Service/Other Manual 2023-01-03 · SB-65 · Service Bulletin/Repair Instructions
it has come to our attention that certain 2022 and 2023 allegro open road motorhomes have the potential for the 8k front hollow rod jack legs to bend or deform under extreme side loads. lippert components inc has issued a service bulletin to replace these certain 8k hollow rod jacks with updated so
Equipment:mechanical:slide-In Camper 2022-02-02 · SB-62 · Service Bulletin/Repair Instructions
instructions were sent on how to reverse the hydraulic lines on the bed slide of the allegro 32 fa motorhome so they slide override will work properly. the problem was that when you used the emergency override button (either "retract" or "extend"), one slide did what it was supposed to do, the bed s
Suspension:rear:axle:non-Powered Axle Assembly 2021-08-04 · CSA-001 · Service Bulletin/Repair Instructions
customer service advisory for ford recall (21s17) regarding low oil volume rear axle
What owners report
2024-02-23 · Unknown Or Other“purchased this rv motorhome in december 2021. from day 1 of this purchase, i have experienced what is being called the "creepy slide syndrome". when the motorhome is parked on in motion, the two hydraulic slides will creep (extend) out about 2-4 inches and at times have been extended as far as 6 inches. have had more than 5 service repairs, incl…”
2024-01-09 · Unknown Or Other“both hydraulic forward slide rooms creep out at will. this unit was purchased new in july 2023 and was in the shop for 3 months having issues addressed. the main issue is that these slide rooms creep/drift out on their own. the dealership says that we don't have the cylinders that were part of a recall. so they bled the existing cylinders and t…”
2023-05-24 · Structure:body“large slide will come out from wall of coach four to six inches while parked and driving. national safety problem issued by manufacturer. repair was done, lasted five months then reoccurred. trying to get fixed again. out of service total of six months and counting. dealer and manufacturer know no recourse will be taken. filed cap rv told not elig…”
Excerpts of consumer complaints filed with NHTSA, lightly truncated. They are owner statements, not verified findings.