2024 Brinkley Rv Model G problems, complaints & recalls
Most-reported problem areas: Service Brakes (1)
Safety recalls (4)
Structure:body:step/Ladder 2025-05-01 · campaign 25V286000 · 1,607 vehicles
Defect: Brinkley RV (Brinkley) is recalling certain 2024-2025 Model G and Model Z fifth wheel travel trailers, equipped with a removable step assembly. The clip-on bracket mounting bolts may come loose, allowing the steps to detach.
Risk: Steps that detach while in use increase the risk of injury.
Fix: Dealers will replace the clip-on bracket as necessary, free of charge. Owner notification letters were mailed May 21, 2025. Owners may contact Brinkley customer service at 1-574-501-4280. Brinkley's number for this recall is REC-2502.
Equipment:electrical:accessory Generator:solar Panel 2025-01-30 · campaign 25V042000 · 1,723 vehicles
Defect: Brinkley RV (Brinkley) is recalling certain 2024-2025 Model G fifth wheel trailers. The solar charge controller may fail and overheat.
Risk: An overheated controller increases the risk of fire.
Fix: Dealers will replace the controller, free of charge. Owner notification letters were mailed February 7, 2025. Owners may contact Brinkley customer service at 1-574-501-4280. Brinkley's number for this recall is REC-2501.
Equipment:electrical:accessory Generator:solar Panel 2024-10-21 · campaign 24V786000 · 1,319 vehicles
Defect: Brinkley RV (Brinkley) is recalling certain 2024-2025 Model G fifth wheel trailers. The solar panels may have been incorrectly wired, which can overload the circuits and cause the wiring to overheat.
Risk: Overheated wires increase the risk of a fire.
Fix: Dealers will rewire the solar power system, free of charge. Owner notification letters were mailed October 29, 2024. Owners may contact Brinkley customer service at 1-574-501-4280. Brinkley's number for this recall is REC-2404.
Electrical System 2023-09-29 · campaign 23V664000 · 143 vehicles
Defect: Brinkley RV is recalling certain 2024 Brinkley RV Model G fifth wheel toy haulers. The power control system was manufactured with undersized 10-gauge wire instead of 6-gauge wire.
Risk: An undersized wire may overheat, increasing the risk of a fire.
Fix: Dealers will replace the power control system, free of charge. Owner notification letters were mailed October 16, 2023. Owners may contact Brinkley customer service at 1-574-501-4280. Brinkley's number for this recall is PCI-2023-01.
Service bulletins (27)
Technical service bulletins are repair instructions manufacturers send dealers for known issues. Unlike recalls, the fix is not automatically free — but naming the bulletin at the service desk can save diagnosis time and support goodwill repairs.
Structure:body 2026-09-08 · WI-113-2026 · Service Bulletin/Repair Instructions
in the unlikely event that the head should break off of a fastener holding the t-molding to a slide-out, the following information provides direction on removing the screw shank and installing a replacement fastener
Unknown Or Other 2026-08-07 · WI-107-2026 · Service Bulletin/Repair Instructions
brinkley rv has determined that under certain conditions on the model g, there is the potential for the rivets around the exterior fridge area to break due to vibration
Unknown Or Other 2026-08-03 · WI-022-2025 REV B · Service Bulletin/Repair Instructions
an update to the document on a field fix of a kitchen pull-out pantry system that won't open properly or is bowed down when extended. this only applies to the kitchen pull out pantry system on a model g fifth wheel.
Structure:body 2026-07-14 · WI-097-2026 · Service Bulletin/Repair Instructions
under different circumstances, it may be necessary to remove and replace the belt rail along a slide-out. the following instructions provide direction for performing this procedure.
Unknown Or Other 2026-04-15 · WI-006-2025 REV-C · Service Bulletin/Repair Instructions
this document refers to the adjustment of a dinesk™ system that won’t close properly or is bowed up when extended. updated affected models
Exterior Lighting 2026-03-23 · WI-003-2024 Rev-B · Service Bulletin/Repair Instructions
updated work instructions to wi-003-2024. this revision (rev b) shows how to replace the decorative light lens cover on the front cap which may peel and allow for water intrusion. this could damage the led light strip behind them.
Showing the 6 most recent of 27 bulletins. Search all of them free at nhtsa.gov.
What owners report
2024-07-03 · Service Brakes“rv batteries (go power brand) went into standby mode. the following morning, after the rv was plugged into shore power (50-amp) all night, batteries did not charge leading to complete loss of brakes while tv was hooked to truck. brinkley rv failed to identify issue or issue safety bulletin/recall to owners. incident occurred in may 2024 in indiana.…”
Excerpts of consumer complaints filed with NHTSA, lightly truncated. They are owner statements, not verified findings.