2024 Brinkley Rv Model Z problems, complaints & recalls
Most-reported problem areas: Service Brakes (1) · Electrical System (1)
Safety recalls (4)
Structure:body:step/Ladder 2025-05-01 · campaign 25V286000 · 1,607 vehicles
Defect: Brinkley RV (Brinkley) is recalling certain 2024-2025 Model G and Model Z fifth wheel travel trailers, equipped with a removable step assembly. The clip-on bracket mounting bolts may come loose, allowing the steps to detach.
Risk: Steps that detach while in use increase the risk of injury.
Fix: Dealers will replace the clip-on bracket as necessary, free of charge. Owner notification letters were mailed May 21, 2025. Owners may contact Brinkley customer service at 1-574-501-4280. Brinkley's number for this recall is REC-2502.
Trailer Hitches:fifth Wheel Assembly 2024-11-22 · campaign 24V885000 · 466 vehicles
Defect: Brinkley RV (Brinkley) is recalling certain 2024-2025 Model Z Fifth Wheel trailers equipped with Curt Helux Pin Boxes. The pin box fasteners may have been improperly tightened.
Risk: The fasteners can loosen and fall out, allowing the tow vehicle to detach from the pin box and increasing the risk of a crash.
Fix: Dealers will tighten the fasteners, free of charge. Owner notification letters were mailed December 12, 2024. Owners may contact Brinkley customer service at 1-574-501-4280. Brinkley's number for this recall is REC-2405.
Equipment:appliance:refrigerator 2024-06-25 · campaign 24V476000 · 3,157 vehicles
Defect: Brinkley RV (Brinkley) is recalling certain 2023-2024 Model Z fifth wheels and Model Z-Air travel trailers. The 12-volt system may have been incorrectly wired without overcurrent protection and with undersized wiring for the refrigerator, which can result in overheating.
Risk: Overheated wiring can increase the risk of a fire.
Fix: Dealers will replace the wiring, free of charge. Owner notification letters were mailed in July 8, 2024. Owners may contact Brinkley customer service at 1-574-501-4280. Brinkley's number for this recall is REC-2402.
Suspension:rear:axle:spindle 2024-01-23 · campaign 24V037000 · 17 vehicles
Defect: Brinkley RV (Brinkley) is recalling certain 2024 Model Z recreational vehicles. The axle spindle weld may fail, resulting in the wheel assembly detaching from the axle.
Risk: Wheel assembly detachment increases the risk of a crash.
Fix: Dealers will inspect and replace the axles as necessary, free of charge. Owner notification letters were mailed in February 05, 2024. Owners may contact Brinkley customer service at 1-574-501-4280. Brinkley's number for this recall is REC-2401.
Service bulletins (40)
Technical service bulletins are repair instructions manufacturers send dealers for known issues. Unlike recalls, the fix is not automatically free — but naming the bulletin at the service desk can save diagnosis time and support goodwill repairs.
Structure:body 2026-09-08 · WI-113-2026 · Service Bulletin/Repair Instructions
in the unlikely event that the head should break off of a fastener holding the t-molding to a slide-out, the following information provides direction on removing the screw shank and installing a replacement fastener
Structure:body 2026-07-14 · WI-097-2026 · Service Bulletin/Repair Instructions
under different circumstances, it may be necessary to remove and replace the belt rail along a slide-out. the following instructions provide direction for performing this procedure.
Unknown Or Other 2026-06-23 · WI-001-2024 REV B · Service Bulletin/Repair Instructions
update to wi-001-2024 model z bed platform repair and vent installation. this is to correct the placement of the bedroom slide-out rollers on the bedroom floor.
Structure:body 2026-05-12 · WI-092-2026 · Service Bulletin/Repair Instructions
model z front cap repositioning instructions.
Unknown Or Other 2026-04-15 · WI-006-2025 REV-C · Service Bulletin/Repair Instructions
this document refers to the adjustment of a dinesk™ system that won’t close properly or is bowed up when extended. updated affected models
Exterior Lighting 2026-03-23 · WI-003-2024 Rev-B · Service Bulletin/Repair Instructions
updated work instructions to wi-003-2024. this revision (rev b) shows how to replace the decorative light lens cover on the front cap which may peel and allow for water intrusion. this could damage the led light strip behind them.
Showing the 6 most recent of 40 bulletins. Search all of them free at nhtsa.gov.
What owners report
2026-04-30 · Electrical System“from the time of purchase we have had an issue with the fuse blowing when we retracted the kitchen slide. we have had our brinkley 5th wheel in for service at approved brinkley locations for this issue multiple times with the issue reproduced. service has occurred for this issue from march 2024 until april 2026. in april 2024 when we picked up t…”
2025-05-08 · Service Brakes“two out of four seals were blowen on the breakdrum and breaks drums contaminated with grease. …”
Excerpts of consumer complaints filed with NHTSA, lightly truncated. They are owner statements, not verified findings.