2025 Bmw I4 Xdrive40 problems, complaints & recalls
Most-reported problem areas: Wheels (1) · Visibility/Wiper (1) · Tether, Lower Anchor (On Car Seat Or Vehicle) (1)
Safety recalls (0)
No recalls on record for this model year (campaigns announced since 2010).
Service bulletins (2)
Technical service bulletins are repair instructions manufacturers send dealers for known issues. Unlike recalls, the fix is not automatically free — but naming the bulletin at the service desk can save diagnosis time and support goodwill repairs.
Structure:body 2026-04-23 · B510626 · Service Bulletin/Repair Instructions
while driving on rough surfaces, a “tapping” noise can be heard from the tailgate area
Steering 2025-12-01 · B121425 · Service Campaign
in certain driving situations there can be a loss of traction or wheel slip followed by a throttle or torque requirement that can potentially damage the axle shafts. damage of the drive shaft can cause it to break.
What owners report
2026-07-03 · Electrical System“charging interrupted-failed. unable to fully use ev. dealer confirms issue & has ev for two weeks, bmw usa has been notified, no remedy offered. …”
2026-06-07 · Engine“entire car was bricked after a software update (03/2026.54). even the gear could not be changed to neutral for placing on a tow truck. nothing wrong with the batteries. after more than 12 hours, finally the engine powered on but the software failure notification sign would still not work, and car had to be towed to authorized service center for a c…”
2026-05-21 · Visibility/Wiper“i was driving last night on the highway in a monster rainstorm in long island, ny. in a full monsoon the wipers stopped working stuck in the up position. i was fortunate to not get in a very serious accident as i was going 50mph with zero visibility. i was able to make it to the side of the road where i drove with my hazards to exit the highway and…”
2026-01-22 · Back Over Prevention: Sensing System: Camera“the backup camera at night is very dark and unsafe. i can barely see anything. it’s a major safety issue even though sensors can warn you, i almost ran over my neighbor while backing out of the garage. my wife has a 2025 x5 that does not have this issue at all. i see online forums where tons of people are complaining about the same issue, mak…”
2026-01-09 · Wheels“my 2025 bmw i4 has experienced two distinct but related tire safety issues involving abnormal wear and repeated structural failures. issue 1: extreme accelerated tire wear the factory-installed tires on my new vehicle were fully worn out in approximately 4 months and ~5,000 miles. all four tires required replacement. this level of wear is far outs…”
2025-12-29 · Tether, Lower Anchor (On Car Seat Or Vehicle)“nuna had a major recall for their rava convertible car seats as your organization is aware of. however, there are two main issues that i'm having that nuna has refused to address nor do they have a viable solution for. the first is that with the recall fix which was new material they sent out, the harness button is covered by fabric and when the ra…”
Excerpts of consumer complaints filed with NHTSA, lightly truncated. They are owner statements, not verified findings.