2025 Kenworth T180 problems, complaints & recalls
Safety recalls (3)
Exterior Lighting:lighting Control Module:software 2025-06-26 · campaign 25V436000 · 56,260 vehicles
Defect: PACCAR Incorporated (PACCAR) is recalling certain 2024-2026 Kenworth T480, T680, T880, W990, Peterbilt 520, 536, 537, 548, 567, 579, 589, 2025 Kenworth T180, Peterbilt 535, 2025-2026 Kenworth T280, T380 and L770 vehicles. The tail brake light, upper and lower beam headlights, reverse light, and turn signal may not illuminate as intended. In addition, the lift axles, if lowered, may revert to a raised position, or oscillate up and down when the signal warning lights are activated. As such, these
Risk: Delayed and unsteady headlights can result in insufficient illumination of the road, decreasing the driver's visibility and increasing the risk of a crash. In addition, an unexpected position change of the lift axles may increase the risk of injury.
Fix: Dealers will update the VCU software, free of charge. Owner letters were mailed August 19, 2025. Owners may contact Kenworth's customer service at 1-425-828-5888 and Peterbilt's customer service at 1-940-591-4220. PACCAR's number for this recall is 25PACF.
Exterior Lighting:lighting Control Module:software 2025-01-29 · campaign 25V041000 · 5,378 vehicles
Defect: PACCAR Incorporated (PACCAR) is recalling certain 2025 Kenworth T180, Peterbilt 535, 567, 2025-2026 Kenworth T280, 2023-2026 Kenworth T380, 2024-2026 Kenworth T480, 2024-2026 Peterbilt 536, 537, and 548 trucks. The exterior lighting switch may fail, resulting in the hazard lights and the instrument display back-light brightness adjustment not functioning. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 101, "Control and Disp
Risk: Inoperative hazard lights cannot alert other drivers as intended. In addition, the inability to adjust the brightness on the instrument panel display can make it difficult to see critical safety information or distract the driver. Both scenarios can increase the risk of a crash.
Fix: Dealers will update the vehicle cab controller unit (VECU) software, free of charge. Owners are advised that a non-responsive switch can be temporarily reset by a key cycle. Owner notification letters were mailed March 26, 2025. Owners may contact Kenworth's customer service at 1-425-828-5888 and Peterbilt's customer service at 1-940-591-4220. PACCAR's numbers for this recall are 25KWB and 25PBB.
Power Train:automatic Transmission:lever And Linkage:column Shift 2024-03-20 · campaign 24V190000 · 70,509 vehicles
Defect: PACCAR Incorporated (PACCAR) is recalling certain 2021-2024 Peterbilt 365, 367, 389, 535, 536, 537, 548, 567, 579, and 2021-2025 Kenworth T180, T280, T380, T480, T680, T880 and W990 trucks. The right-hand gear shifter stalk connectors may have been improperly crimped, resulting in a loss of communication.
Risk: A loss of communication between the gear shifter and the transmission may result in the vehicle becoming disabled after coming to a stop, increasing the risk of a crash.
Fix: Dealers will inspect and replace the gear shifter assembly as necessary, free of charge. Owner letters were mailed December 15, 2025, then phased after that. Owners may contact Kenworth customer service at 1-425-828-5888 or Peterbilt customer service at 1-940-591-4220. PACCAR's numbers for this recall are 24PBE and 24KWE.
Service bulletins (20)
Technical service bulletins are repair instructions manufacturers send dealers for known issues. Unlike recalls, the fix is not automatically free — but naming the bulletin at the service desk can save diagnosis time and support goodwill repairs.
Unknown Or Other 2026-10-28 · 99-050 · Service Bulletin/Repair Instructions
there is an update to the carb base emissions warranty limits table and manufacturer’s warranty coverage section in certain engine model year (emy) 2024-2026 px-7 and px-9 operator’s manuals.
Electrical System 2026-10-23 · 37-007 · Service Bulletin/Repair Instructions
eaton service bulletin taib-1026 instructs dealers to update the master switch module (msm) software. the update must be completed before performing a davie4 learn dash switches procedure to fix intermittent dash switch functionality.
Engine 2026-09-11 · P001 · Service Bulletin/Repair Instructions
"kenworth: dealers should check the chassis list and sir weekly for vin changes. 2 chassis added to the chassis list. peterbilt: dealers should check the chassis list and sir weekly for vin changes. 10 chassis added to the chassis list."
Electrical System 2026-06-03 · 43-080 · Service Bulletin/Repair Instructions
"kw: a new recommended repair has been added to verify the software level and close the campaign in sir.the repair procedure has been updated with additional note boxes for clear instructions. pb: the repair procedure has been updated with additional note boxes for clear instructions."
Electrical System 2026-05-06 · 02-177 · Service Bulletin/Repair Instructions
troubleshooting procedures for 2.1m cab power windows are now available.
Electrical System 2026-02-11 · 24PBE_KWE · Service Bulletin/Repair Instructions
the parts section has been updated to clarify that freight charges for safety recall orders should not be passed on to the end customer.
Showing the 6 most recent of 20 bulletins. Search all of them free at nhtsa.gov.
What owners report
No detailed complaint narratives on file.
Excerpts of consumer complaints filed with NHTSA, lightly truncated. They are owner statements, not verified findings.