2026 Volvo Vah problems, complaints & recalls
Safety recalls (3)
Steering:linkages:knuckle:spindle:arm 2026-07-09 · campaign 26V444000 · 3,858 vehicles
Defect: Volvo Trucks North America (Volvo Trucks) is recalling certain 2026 VOLVO VAH, VN, VHD, 2026-2027 VNL (4) and VNR (4) vehicles. The steering knuckles may have been manufactured with insufficiently tightened steering arms.
Risk: A loose steering arm can result in a loss of vehicle steering control, increasing the risk of a crash.
Fix: Dealers will inspect and tighten the fasteners between the steering arm and steering knuckle, as necessary, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Volvo Trucks' customer service at 800-528-6586. Volvo Trucks' number for this recall is RVXX2607. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 16, 2026.
Wheels:lugs/Nuts/Bolts/Studs 2026-05-28 · campaign 26V350000 · 205 vehicles ⚠ DO NOT DRIVE
Defect: Volvo Trucks North America (Volvo Trucks) is recalling certain 2026 VAH, 2026-2027 VN, VHD, VNL (4), and 2027 VNR (4) vehicles. The wheel lug nuts may loosen and allow the wheel to detach.
Risk: Wheel detachment can cause a loss of vehicle control or create a road hazard, increasing the risk of a crash or injury.
Fix: Owners are advised not to drive their vehicles until the repair has been performed. Dealers will inspect the wheel and hub mating surfaces, remove any masking material, and replace any worn components if necessary, free of charge. Owner notification letters were mailed June 15, 2026. Owners may contact Volvo Trucks' customer service at 800-528-6586. Volvo Trucks' number for this recall is RVXX2606.Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May
Seat Belts:front:anchorage 2025-11-03 · campaign 25V753000 · 242 vehicles
Defect: Volvo Trucks North America (Volvo Trucks) is recalling certain 2019-2026 VAH trucks. The passenger seat belt anchor may fail due to inadequate floor reinforcement. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."
Risk: A seat belt anchor that fails will not properly restrain an occupant in a crash, increasing the risk of injury.
Fix: Dealers will install a new weld nut and washer, free of charge. Owner notification letters were mailed December 16, 2025. Owners may contact Volvo Trucks' customer service at 1-800-528-6586. Volvo Trucks' number for this recall is RVXX2510. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning November 10, 2025.
Service bulletins (13)
Technical service bulletins are repair instructions manufacturers send dealers for known issues. Unlike recalls, the fix is not automatically free — but naming the bulletin at the service desk can save diagnosis time and support goodwill repairs.
Electrical System 2026-09-21 · TSB 373-001 202609 · Service Bulletin/Repair Instructions
overheating has been observed at the alternator power cable and ground cable connection, resulting in melted insulation around the terminal area. the alternator power cable connection should maintain a stable electrical contact without overheating or insulation damage during normal vehicle operat
Unknown Or Other 2026-09-17 · CBR 2398 202609 · Service Bulletin/Repair Instructions
this cbr solution addresses the issue of binding between the outer air filter housing and inner hvac box due to misalignment during installation.
Electrical System 2026-09-14 · TSB 371-005 202609 · Service Bulletin/Repair Instructions
the eld connected to the rp1226 connector in the truck remains powered on always. as a result in the batteries being depleted within a very short amount of time (a few hours after the truck is shut down).
Engine 2026-06-22 · CBR-2592-1 202606 · Service Bulletin/Repair Instructions
the purpose of this cbr is to provide steps on how to correct a customer complaint of dtc p107b86 accompanied with intermittent loss of throttle.
Air Bags 2026-05-29 · RD26-2 202605 · Over The Air
if you have received this document, it is because one or more of the following faults has been active for at least 5 minutes and can potentially prevent the supplemental restraint system/airbag inflation system (srs) from functioning properly in the event of a collision. tech tool will need to be us
Electrical System 2026-03-19 · CBR 2172-7 032026 · Service Bulletin/Repair Instructions
cbr - no start condition after over the air programing - vecu5 no start "safe state"
Showing the 6 most recent of 13 bulletins. Search all of them free at nhtsa.gov.
What owners report
No detailed complaint narratives on file.
Excerpts of consumer complaints filed with NHTSA, lightly truncated. They are owner statements, not verified findings.