2003 Gmc Envoy problems, complaints & recalls
Most-reported problem areas: Fuel System, Gasoline (35) · Electrical System (32) · Fuel/Propulsion System (22)
🧭 Reliability snapshot
Compared against other Gmc Envoy model years — complaint volume vs the model's median year, recalls and severity. How we score →
🛣️ Complaints by mileage
297 NHTSA complaints that reported an odometer reading.
Safety recalls (0)
No recalls on record for this model year (campaigns announced since 2010).
Service bulletins (682)
Technical service bulletins are repair instructions manufacturers send dealers for known issues. Unlike recalls, the fix is not automatically free — but naming the bulletin at the service desk can save diagnosis time and support goodwill repairs.
Unknown Or Other 2025-07-18 · PIP5601C · Service Bulletin/Repair Instructions
this pi communicates the requirement to provide a pico file to receive diagnostic assistance from tac.
Unknown Or Other 2025-02-20 · PIP5358D · Service Bulletin/Repair Instructions
this preliminary information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. technician should get record a sound clip or take a video of the noise for assessment by engineering. technician will need to
Electrical System 2024-10-25 · PIP4723J · Service Bulletin/Repair Instructions
this preliminary information communicates to the dealer the process for downloading or updating operating software for the tire pressure monitor, active fuel injector tester, multi media tester, pico scope, gr8 starting/charging tester and vehicle data recorder tools, giving website address and ste
Unknown Or Other 2024-09-12 · PIT5099H · Service Bulletin/Repair Instructions
this preliminary information communication provides information to the technician about vehicles that the heater-vent-air conditioning blows warm air. before calling general motors technical assistance center technician will need to have high and low pressures, outside temperature, humidity, and ven
Unknown Or Other 2024-09-12 · PIT5099H · Service Bulletin/Repair Instructions
this preliminary information communication provides information to the technician about vehicles that the heater-vent-air conditioning blows warm air. before calling general motors technical assistance center technician will need to have high and low pressures, outside temperature, humidity, and ven
Unknown Or Other 2024-09-06 · PIT3271P · Service Bulletin/Repair Instructions
this preliminary information communication provides information to the technician about changing the tire and wheel size on vehicles. general motors will only support a tire calibration for tires that have been sized, tested and designed for the vehicle in question and its applications. technician s
Showing the 6 most recent of 682 bulletins. Search all of them free at nhtsa.gov.
What owners report
2026-10-13 · Fuel/Propulsion System“i can not put gas in my car. m garage smells of gas fumes. very dangerous situation of possible fire or illness due to fumes ans i have no transportation. when i bought this car from gmc it had the sam problem. no recall just a safety bulletin. manufacturer fixed it.there were no warning lights.…”
2026-07-27 · Visibility/Wiper“my windshield wipers come on when you start the car, or when you just click the switch to put windows up, but the wiper switch is off. the wipers stay operating from 5 to 10 minutes before they shut off, and i am concerned the windshield and/or wipers may become damaged. this issue has just started to occur within the last week. there have been no …”
2026-03-12 · Engine · 98,000 mi“the contact owns a 2003 gmc envoy. the contact stated that while in drive(d), the vehicle shut off and then restarted. the message “service engine soon” was displayed. the vehicle was taken to the local dealer, where it was diagnosed and determined that the instrument cluster needed to be replaced. the vehicle was repaired, but the failure reoccurr…”
2026-02-02 · Suspension · 66,411 mi“the contact owns a 2003 gmc envoy. the contact stated that while the vehicle was parked on several occasions, there was condensation under the front of the vehicle. the vehicle was taken to a dealer on several occasions, where it was determined that the differential needed to be repaired due to a leak coming from the axle. on several occasions, it …”
2025-07-06 · Electrical System:instrument Panel:fuel Gauge“the car's gas gauge and fuel range indicator are problematic. the fuel gauge quickly drops from a higher reading, like 3/4 full, to empty. after this, the gauge and the fuel range both fluctuate while driving, making it impossible to determine the fuel level.…”
2025-07-06 · Unknown Or Other“fuel indicator bounces from empty to full in the matter of seconds while going down the road. also, issues with mileage range reported as the fuel indicator is fluctuating. …”
2024-09-19 · Structure:body“i bought a 2003 gmc envoy 3/23/24. the main frame and sub-frame have extensive rot, and is unsafe to drive. it is available to inspect. they disguised frame damage and sold me an unsafe vehicle. i brought the car in to have the ac repaired in august 2024 and when they put it up on the lift that's when they saw the damage. this was rogers automotiv…”
2024-05-27 · Exterior Lighting“issue: hazard warning/turn signal flasher module failure. description: right front and rear turn signal and right front and rear hazard warning not working outside or inside vehicle. replaced burned out right front turn signal/hazard. replaced right rear turn signal/hazard due to corrosion on base of bulb. looked at fixtures when replacing and all …”
2023-04-05 · Exterior Lighting“the contact owns a 2003 gmc envoy. the contact stated that the headlights ceased to operate as needed. upon taking the vehicle to a local pep boys, it was diagnosed that the electrical wiring harness was burned and needed to be replaced. additionally, the bulbs needed to be replaced. the contact stated that the vehicle was repaired; however, the fa…”
2021-10-08 · Structure:body“rear door will not open. window works but door handles inside and outside will not unlock door to open.…”
Excerpts of consumer complaints filed with NHTSA, lightly truncated. They are owner statements, not verified findings.