2010 Four Winds Hurricane problems, complaints & recalls
Most-reported problem areas: Equipment:recreational Vehicle/Trailer (1) · Electrical System (1)
Safety recalls (3)
Equipment:recreational Vehicle/Trailer 2015-11-10 · campaign 15V745000 · 12,656 vehicles
Defect: Thor Motor Coach (Thor) is recalling certain model year 2011-2016 Thor Challenger, Thor Citation, Thor Hurricane, Thor Tuscany, Thor Windsport, 2011-2012 Thor Astoria, Thor Avanti, Thor Chateau, 2011-2014 Thor Daybreak, 2011-2015 Thor Outlaw, Thor Siesta, 2014-2015 Thor Miramar, 2012 Thor Four Winds, 2008-2011 Damon Astoria, Damon Daybreak, Damon Outlaw, Damon Tuscany, 2008-2012, Damon Challenger, 2008-2010 Damon Essence, 2009-2011 Damon Avanti, Four Winds Chateau, Four Winds Citation, Four Wind
Risk: Unstable entry and exit steps increase the risk of injury.
Fix: Thor will notify owners, and dealers will install a retainer bracket to reinforce the operating mechanism and replace all of the affected bolts, free of charge. The recall began on January 6, 2016. Owners may contact Thor customer service at 1-877-855-2867. Thor's number for this recall is RC000111.
Electrical System 2015-10-23 · campaign 15V698000 · 503 vehicles
Defect: Thor Motor Coach (TMC) is recalling certain model year 2009-2011 Four Winds Hurricane and Windsport, 2009-2010 Four Winds Mandalay, 2010 Four Winds Magellan, and 2010-2011 Four Winds Serrano motorhomes manufactured May 2, 2009, to September 1, 2010. The affected vehicles are wired to be powered by a generator and are equipped with an Iota ITS-50R transfer switch that may fail when exposed to elevated electrical loads and used in higher ambient temperatures.
Risk: As the transfer switch fails, it may overheat, increasing the risk of a fire.
Fix: TMC will notify owners, and dealers will replace the Iota ITS-50R transfer switch with a transfer switch from another manufacturer, free of charge. The recall began on November 23, 2015. Owners may contact Thor customer service at 1-877-855-2867. Thor's number for this recall is RC000106.
Electrical System 2012-10-22 · campaign 12V516000 · 634 vehicles
Defect: Thor Motorcoach is recalling certain model year 2008-2010 motorhomes, manufactured June 1, 2007, through May 1, 2009 and equipped with an Iota ITS-50R Transfer Switch. The models affected are Four Winds brand models: Chateau, Dutchmen, Hurricane, Windsport, Magellan, Fun Mover, Presidio, and Mandalay. Wiring connections inside the transfer switch are not adequate and, as a result, the switch may overheat.
Risk: An overheated switch could cause it to fail and lead to a fire.
Fix: Thor Motorcoach will notify owners and replace the Iota Transfer Switch, free of charge. The safety recall began on November 16, 2012. Owners may contact Thor at 1-877-500-1020.
Service bulletins (2)
Technical service bulletins are repair instructions manufacturers send dealers for known issues. Unlike recalls, the fix is not automatically free — but naming the bulletin at the service desk can save diagnosis time and support goodwill repairs.
Equipment:other:owners/Service/Other Manual 2017-11-03 · LTR 110317 · Service Bulletin/Repair Instructions
this letter stated that there was one (1) service notification issued for the month of october, 2017.
Visibility:windshield Wiper/Washer 2010-12-08 · TSB-10-008 · Service Bulletin/Repair Instructions
four winds international: wiper pivots have been installed correctly causing the wipers to have incorrect wipe angles. *rm
What owners report
2013-09-19 · Equipment:recreational Vehicle/Trailer“2010 four winds hurricane. consumer requests reimbursement for battery control center repairs and writes in regards to replacement of leaking black water tank. *smd the consumer received a call from a representative stating the claim was denied, because the incident was not related to the recall. his reasoning for denying the claim, was becaus…”
2013-03-14 · Electrical System“the customer reported an incident with their motor-home. it appears that the iota its50-r switch failed while in use. the motor-home was stationary and hooked into 50a shore power. the customer reported that in the middle of the night they heard a popping noise and smelled something like burning rubber. the customer checked the voltage at their out…”
Excerpts of consumer complaints filed with NHTSA, lightly truncated. They are owner statements, not verified findings.