2009 Mercedes-Benz Sprinter 3500 problems, complaints & recalls
Most-reported problem areas: Exterior Lighting (1)
🧭 Reliability snapshot
Compared against other Mercedes-Benz Sprinter 3500 model years — complaint volume vs the model's median year, recalls and severity. How we score →
Safety recalls (1)
Equipment Adaptive/Mobility 2014-11-05 · campaign 14V706000 · 34 vehicles
Defect: Cummings Mobility Conversion & Supply (Cummings) is recalling certain model year 2006-2014 Ford E-150, E-250, E-350, Chevrolet Express, 2006-2008 Dodge Sprinter, and 2009-2014 Mercedes-Benz Sprinter, and 2013 Ford Transit Connect vehicles manufactured January 1, 2006, to October 8, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may cr
Risk: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Fix: Cummings will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began January 13, 2015. Owners may contact Cumming's customer service at 1-800-639-5438 or Ricon customer service at 1-800-322-2884. Cumming's number for this recall is 14E-041.
Service bulletins (97)
Technical service bulletins are repair instructions manufacturers send dealers for known issues. Unlike recalls, the fix is not automatically free — but naming the bulletin at the service desk can save diagnosis time and support goodwill repairs.
Unknown Or Other 2026-09-19 · LI82_85_N_080972_1 · Service Bulletin/Repair Instructions
unavailability of mb apps complaint a popup is seen on the hu with the message "data connection temporarily not available". cause mb apps is officially sundowned for all vehicles with ntg5 head unit variant. remedy no support available for ntg5 head unit variants for mb app related topics.
Power Train 2026-08-26 · LI28_00-N-079097_1_en · Service Bulletin/Repair Instructions
complaint while driving through muddy / sandy/ off road terrain "4matic currently unavailable" message on the dash cause this vehicle is not equipped with a fixed force distribution awd, rather force is only applied to the front axle according to esp calculations. as per gf28.00‑d‑ 9900a: "vehicles
Unknown Or Other 2026-07-01 · LI54_30-N-080701 · Service Bulletin/Repair Instructions
assyst plus service reminder appears earlier than expected due to vehicle operating conditions complaint the assyst plus service reminder appears earlier than expected. the customer or dealer may report that the vehicle did not reach the starting maintenance interval shown in vehicle documentation
Power Train 2026-06-15 · LI14.20-N-073867 · Service Bulletin/Repair Instructions
complaint complaint a: the engine is jolting/bucking between 1700 and 1900 rpm. complaint b: one or more mechanical related fault codes for egr valve stored in cdi control unit, with possible check engine light. review list of mechanical fault codes in table below. note: if one or more electrical r
Fuel/Propulsion System 2026-06-03 · LI49.10-N-080528 · Service Bulletin/Repair Instructions
om642 dpf filter cracked or broken complaint vehicle will not start or exhibits noisy exhaust. check engine lamp (cel) is on. multiple control unit communication and system faults may be present, including but not limited to: 134800, 134900, 11b300, 11ec00, 15e100, 155700, 162500. additional event
Engine 2026-04-18 · LI4910-N-060969 · Service Bulletin/Repair Instructions
complaint rattling noise from underneath the vehicle. cause one or more of the following conditions may be present: 1. the exhaust bracket from the dpf to the transmission is cracked or broken. • see pic. 1 for an example of a broken bracket. 2. transmission bell housing cracked or broken at the exh
Showing the 6 most recent of 97 bulletins. Search all of them free at nhtsa.gov.
What owners report
2020-02-14 · Exterior Lighting · 142,000 mi · 🔥 fire“tl* the contact owns a 2009 mercedes-benz ml350. the contact stated that the tail light and the paint around it burned without warning. the contact opened the vehicle and found the interior of the vehicle completely burned. there was no police or fire report and no injury was reported. the contact stated that the fire might have burned for days but…”
Excerpts of consumer complaints filed with NHTSA, lightly truncated. They are owner statements, not verified findings.